Air Conditioning System
- Manual
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- Repair Instructions
- O-ring Replacement
- Handling Refrigerant
- Handling of Refrigerant Lines and Fittings
- Maintaining Chemical Stability in the Refrigeration System
- Discharging, Adding Oil, Evacuating and Charging Procedures for A/C System
- Components Used in Non-A/C Systems
- A/C Pressure Transducer Removal
- A/C Pressure Transducer Installation
- A/C Compressor Relay Removal
- A/C Compressor Relay Installation
- Air Filter Removal
- Air Filter Installation
- A/C Expansion Valve Removal
- A/C Expansion Valve Installation
- A/C Module Removal
- A/C Module Installation
- A/C High-Pressure Pipe Line Removal
- A/C High-Pressure Pipe Line Installation
- Heater Core Removal
- Heater Core Installation
- Evaporator Core Removal
- Evaporator Core Installation
- A/C Suction Hose Assembly Removal
- A/C Suction Hose Assembly Installation
- A/C Discharge Hose-Compressor to Condenser Removal
- A/C Discharge Hose-Compressor to Condenser Installation
- Receiver-Dryer Removal
- Receiver-Dryer Installation
- Compressor Removal
- Compressor Installation
- Condenser Removal
- Condenser Installation
- V5 Compressor Components
- Clutch Plate and Hub Assembly Disassembly
- Clutch Plate and Hub Assembly Reassembly
- Clutch Rotor and Bearing Disassembly
- Clutch Rotor and Bearing Assembly
- Clutch Coil Removal
- Clutch Coil Installation
- Shaft Seal Removal
- Shaft Seal Installation
- Control Valve Assembly Removal
- Control Valve Assembly Installation
- Rear Head, Gasket, Valve Plate, Reed Plate and O-ring Removal
- Rear Head, Gasket, Valve Plate, Reed Plate and O-ring Installation
- Cylinder-to-Front Head O-ring Removal
- Cylinder-to-Front Head O-ring Installation
- Leak Testing (External)
- Specifications
- Special Tools and Equipments
- Automatic
- General Description
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- General A/C Diagnostics
- Self-Diagnostic Circuit Check
- Automatic Temperature Controller Does Not Operate When Ignition Is ON
- Controller Does Not Illuminate When Light Switch Is ON
- No Hot Air from Blower
- No Cool Air from Blower
- Blower Motor Does Not Run at All
- Mode Control Do Not Work
- Air Source Selection Not Controlled
- Compressor Magnetic Clutch Does Not Engage
- Code 1 - In-Car Sensor Error
- Code 2 - Ambient Air Temperature Sensor Error
- Code 3 - Coolant Temperature Sensor Error
- Code 4 - Air Mix Door Error
- Code 5 - Sun Sensor Error
- Code 6 - Power Transistor Error
- Code 7 - Max-Hi Relay Error
- Repair Instructions
- General Service Procedures
- Common HVAC Components
- Automatic Temperature Control Assembly Removal
- Automatic Temperature Control Assembly Installation
- Inlet Air Door Motor Removal
- Inlet Air Door Motor Installation
- Mode Door Motor Removal
- Mode Door Motor Installation
- Temperature Door Motor Removal
- Temperature Door Motor Installation
- Coolant Temperature Sensor Removal
- Coolant Temperature Sensor Installation
- Ambient Air Temperature Sensor Removal
- Ambient Air Temperature Sensor Installation
- In-Car Temperature Sensor Removal
- In-Car Temperature Sensor Installation
- Sun Sensor Removal
- Sun Sensor Installation
- A/C Module Removal
- A/C Module Installation
- High-Blower Relay Removal
- High-Blower Relay Installation
- Power Transistor Removal
- Power Transistor Installation
- Air Filter Removal
- Air Filter Installation
- A/C Expansion Valve Removal
- A/C Expansion Valve Installation
- Heater Core Removal
- Heater Core Installation
- Evaporator Core Removal
- Evaporator Core Installation
- Compressor Overhaul
- Specifications