Technical Service Bulletins

A/C Compressor
- Air Conditioning Compressor Noise Upon Initial Operation (SI-0011)
Accessories & Equipment
- Pass-Thru Reprogramming Software Version 1.8.3.0 (TS 04 11106R)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Accessories Control Systems
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- Clock Will Not Hold Memory When Ignition Key Is Turned Off (TS 03 04054)
Air Bag, SRS
- Replacing The S.I.R. Clock Spring (TS 01 02244)
Anti-Theft Systems
- Driver Door Lock Tumbler Falls Into Door When The Key Is Inserted (TS 06 05115R)
- Service Manual Update For Programming Keyless Transmitters (TS 02 03044)
Automatic Trans
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 04022R2)
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 12200)
- Automatic Transmission Shift Lever Is Loose In The Shift Gate And/Or Ignition Key Cannot Be Removed (TS 09 03129R)
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 12018R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Ignition Key Will Not Come Out Of Ignition Switch (TS 04 12056)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- DTC P0703 Explained (TS_03_11075)
- ECM Reprogramming For High Idle, Rough Idle/Stall (TS_03_09295R)
- Automatic Transmission Harsh 2 To 1 Downshift (TS_01_08055)
- Harsh 4TH To 3RD Automatic Transmission Downshift And Unwanted P1884 DTC (TS_02_08055)
- Crankshaft Position Variation Learn (TS 02 12174)
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 03222R)
Auxiliary Emission Control Systems
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
- P0441 Or P0496 (Evaporative Emission System Continuous Purge Flow) (TS 08 08106)
Body Electrical
- Safety Recall Campaign "NB" Low Beam Headlight And Daytime Running Light (DRL) Splice Pack Repair (TS 11 10177R2)
- Wire Harness Insulation Damage Behind The Left Front Fender Liner (TS_08_08115)
Body Interior
- Clock Will Not Hold Memory When Ignition Key Is Turned Off (TS 03 04054)
Clutch
- Crankshaft Position Variation Learn (TS 02 12174)
Cooling System (Mechanical)
- Correct Coolant Usage (TS 01 12086R2)
- Water Pump Leak (TS 06 03296)
- Correct Coolant Usage (TS 02 01074)
- Correct Coolant Usage (TS 01 01074)
Engine Control Systems
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor (TS 24 10180)
- P0441 Or P0496 (Evaporative Emission System Continuous Purge Flow) (TS 08 12177R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- ECM Reprogramming For High Idle, Rough Idle/Stall (TS_03_09295R)
- ECM Reprogramming For High Idle, Rough Idle/Stall (TS 03 06035)
- Crankshaft Position Variation Learn (TS 02 12174)
- Fuel Line Disconnecting Procedure (TS 04 12174)
- Fuel Line Disconnecting Procedure (TS 01 12174)
Entertainment Systems
- Radio Static Noise Or No Reception On Am Band Stations (TS_07_10215R)
- Radio Static Noise Or No Reception On Am Band Stations (TS 06 04145)
Exterior Lights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)
Front Suspension
- Inspection And Maintenance Reminder Lower Arm Ball Joint (TS 01 11298)
- Noise From The Front Stabilizer Bar Bushings (TS 02 08317R2)
- Noise From The Front Stabilizer Bar Bushings (TS 02 05135)
Fuel System
- Fuel Line Disconnecting Procedure (TS 04 12174)
- Fuel Line Disconnecting Procedure (TS 01 12174)
Fuses & Circuit Breakers
- Clock Will Not Hold Memory When Ignition Key Is Turned Off (TS 03 04054)
- Replacing The S.I.R. Clock Spring (TS 01 02244)
Gauges & Instrument Panels
- Clock Will Not Hold Memory When Ignition Key Is Turned Off (TS 03 04054)
Headlights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)
- Safety Recall Campaign "NB" Low Beam Headlight And Daytime Running Light (DRL) Splice Pack Repair (TS 11 10177R2)
Ignition Switch/Steering Lock
- Automatic Transmission Shift Lever Is Loose In The Shift Gate And/Or Ignition Key Cannot Be Removed (TS 09 03129R)
- Ignition Key Will Not Come Out Of Ignition Switch (TS 04 12056)
Interior/Exterior Trim
- Technician/Vehicle Owner "Best Practices": Inspecting, Removing, And Installing Floor Mats In SUZUKI Vehicles (TS 03 07210)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Lubrication System
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- FORENZA Oil Leak At The Crankshaft Rear Main Seal, "Causes And Precautions" When Installing The Oil Pan (SI-0008)
- Oil Leak Identification (TS 07 07018)
- Oil Leak From Drain Plug (TS_06_10245)
Manual Steering
- Power Steering Oil Leak Identification (TS 02 10278)
Manual Trans
- Manual Transmission Stuck In 5TH Gear Model(S): FORENZA Sedan/Wagon, RENO (RQ420) (TS 07 07188)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- ECM Reprogramming For High Idle, Rough Idle/Stall (TS_03_09295R)
Mechanical
- Oil Pump Pressure Switch Relocation When Replacing The Oil Pump (TS 30 06263)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Rubbing Noise Coming From Front (Timing Belt Cover) Area Of Engine (TS 21 03259)
- Valve Cover Gasket Replacement (TS 15 04067)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Crankshaft Position Variation Learn (TS 02 12174)
Mechanical - Hydraulic
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Brake Noise Characteristics During Normal Operation (TS_01_10265)
- Rear Brake Noise (TS_02_09075)
Paint & Coatings
- Possible Paint Peeling On Door Frame (TS 04 09024)
Passive Restraints
- Slow And/Or Incomplete Retraction Of Seat Belts (TS 02 02274)
Restraints Control Systems
- Replacing The S.I.R. Clock Spring (TS 01 02244)
Seats
- Loose Seat Cushion Cover (TS 09 05226R)
- Slow And/Or Incomplete Retraction Of Seat Belts (TS 02 02274)
Steering Column
- A Noise Can Be Heard Similar To Growling Or Rubbing When Turning The Steering Wheel Left Or Right, Most Noticeable When Parking (TS 01 04286)
- Replacing The S.I.R. Clock Spring (TS 01 02244)
Steering Gear
- Power Steering Oil Leak Identification (TS 02 10278)
System
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Catalyst System (TS 28 10220)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: EGR (Exhaust Gas RECIRCULATION) (TS 26 10200)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Evaporative Emission System (TS 27 10210)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor Heater (TS 25 10190)
- On-Board Diagnostic (OBD) System DTC Confirmation Procedure: Oxygen Sensor (TS 24 10180)
- Engine Has No Power, Hesitates, Stumbles On Acceleration, Check Engine Light Is On With Multiple DTCS With P161B (Control Module Torque Performance) As The Primary DTC (TS 18 02228)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- P0441 Or P0496 (Evaporative Emission System Continuous Purge Flow) (TS 08 08106)
- Crankshaft Position Variation Learn (TS 02 12174)
- Fuel Line Disconnecting Procedure (TS 04 12174)
- Fuel Line Disconnecting Procedure (TS 01 12174)
Transmission Control Systems
- Automatic Transmission Harsh Shift With Mil On And Either Of The Following DTCS; P0783, P0734 (TS 08 12018R)
- Required Automatic Transmission Control Module Initialization Procedure (TS 06 01238)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- DTC P0703 Explained (TS_03_11075)
- ECM Reprogramming For High Idle, Rough Idle/Stall (TS_03_09295R)
- Automatic Transmission Harsh 2 To 1 Downshift (TS_01_08055)
- Harsh 4TH To 3RD Automatic Transmission Downshift And Unwanted P1884 DTC (TS_02_08055)
Wheels & Tire System
- Plastic Wheel Lug Nut Caps Breaking During Wheel Cover Installation. (TS 01 11263)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Pigtail Installation For DRL Module And/Or Signal Switch (TS 15 10244)
- Replacing The S.I.R. Clock Spring (TS 01 02244)