Technical Service Bulletins

A/C Compressor
- Authorized Air Conditioning Refrigerant (TS 001 03226(R))
Accessories & Equipment
- Pass-Thru Reprogramming Software Version 1.8.3.0 (TS 04 11106R)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Accessories Control Systems
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
Air Bag, SRS
- Air Bag On/Off Switch Installation Instructions (TS 10-1 04210)
- Essential Special Tools - Air Bag Load Tool (TS 012 09145(R))
Anti-Lock Brakes
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
- Tech 1-A Cartridges - Models & Special Tools (TS 002 02236(R))
Anti-Theft Systems
- Security System Diagnostic/Parts Replacement Guide (TS 005 08115(R))
Automatic Trans
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 04022R2)
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 12200)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Torque Converter Installation (TS 07-1 04199)
- Modification Of 4-Speed Automatic Internal Parts (TS 3-30 06207)
- TCC Relay Control System Diag - ECM Modification (TS 3-25 05176(R))
- Modification Of Automatic Transmission (TS 3-26 01126)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Auxiliary Emission Control Systems
- Service Manual Update (TS 03 07113)
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Addition Of Throttle Position Sensor (TS 4-28 09197)
- Vibration Noise At 2100-2300 Rpm Catalytic Converter (TS 4-27 04117)
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- TCC Relay Control System Diag - ECM Modification (TS 3-25 05176(R))
- Tech 1-A Cartridges - Models & Special Tools (TS 002 02236(R))
- OBD II - Non Vehicle Induced Faults (TS 015 12125)
- Modification In Duty Cycle Adjustment Procedure (TS 4-29 01098)
Axle Shafts
- Automatic Free Wheel Hub Modification (TS 5-09 10046)
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
- Wheel Spindle Modification - Front (TS 5-08 05246)
- Transfer Case Bind-Up (TS 3-02 02096(R))
Blowers, Superchargers & Turbochargers
- Camshaft Timing Sprocket Bolt And Crankcase Bolt (TS 4-24 07196)
- Crankshaft Timing Belt Pulley Bolt (TS 4-25 07196)
- Crankshaft Timing Belt Pulley Bolt Tightening Torque (TS 4-23 07196)
Body Interior
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Modification Of Fuel Pump Operating Condition By ECM (TS 4-21 11016(R))
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
Brakes Control Systems
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- Tech 1-A Cartridges - Models & Special Tools (TS 002 02236(R))
Charging Systems
- Camshaft Timing Sprocket Bolt And Crankcase Bolt (TS 4-24 07196)
- Crankshaft Timing Belt Pulley Bolt (TS 4-25 07196)
- Crankshaft Timing Belt Pulley Bolt Tightening Torque (TS 4-23 07196)
Communication Devices
- Security System Diagnostic/Parts Replacement Guide (TS 005 08115(R))
Cooling System (Mechanical)
- Water Pump Leak (TS 06 03296)
- Correct Coolant Usage (TS 02 01074)
- Correct Coolant Usage (TS 01 01074)
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
Differentials & Drive Axles
- Bevel Pinion Mounting Distance (TS 01 07084)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
- Transfer Case Bind-Up (TS 3-02 02096(R))
Driveshaft & Universal Joints
- Transfer Case Bind-Up (TS 3-02 02096(R))
Electronic Steering
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Electronic Suspension
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Engine Control Systems
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Addition Of Throttle Position Sensor (TS 4-28 09197)
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- TCC Relay Control System Diag - ECM Modification (TS 3-25 05176(R))
- Tech 1-A Cartridges - Models & Special Tools (TS 002 02236(R))
- OBD II - Non Vehicle Induced Faults (TS 015 12125)
- Modification In Duty Cycle Adjustment Procedure (TS 4-29 01098)
Exhaust
- Vibration Noise At 2100-2300 Rpm Catalytic Converter (TS 4-27 04117)
Exterior Body Panels
- Safety Recall Campaign S1, Fuel Tank Gussets (TS 1-10 06286)
- Fuel Gauge Unit - Modification (TS 4-22 05106)
Front Suspension
- Safety Recall Campaign W2 Front Strut Reinforcement (TS 03-01 03030)
- Strut Tower Bar Bolts & Nuts Tightening Torque (TS 1-12 07117)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Fuel System
- Service Manual Update (TS 03 07113)
Fuses & Circuit Breakers
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- 1996 New Vehicle Dealer Deliveries - Mil Illuminated (TS 013 08115)
Gauges & Instrument Panels
- Fuel Gauge Unit - Modification (TS 4-22 05106)
HVAC Control Systems
- Authorized Air Conditioning Refrigerant (TS 001 03226(R))
Identification
- Plastic Sheet & Splash Guard Modifications (1-09 10256(R))
- Safety Recall Campaign S1, Fuel Tank Gussets (TS 1-10 06286)
Ignition System
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
Interior/Exterior Trim
- Technician/Vehicle Owner "Best Practices": Inspecting, Removing, And Installing Floor Mats In SUZUKI Vehicles (TS 03 07210)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Plastic Sheet & Splash Guard Modifications (1-09 10256(R))
Locking Hubs
- Automatic Free Wheel Hub Modification (TS 5-09 10046)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
- Transfer Case Bind-Up (TS 3-02 02096(R))
Lubrication System
- Oil Leak Identification (TS 07 07018)
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Manual Steering
- Power Steering Pump Service Procedure Modification (TS 5-10 04187)
- Upper Boot For Lower Steering Shaft - New Part Avail (TS 3-29 10256)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Manual Trans
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Service Manual Update On Selection Method Of The Standard Size Connecting Rod Bearing (TS 02 021003)
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Revised Crank Pin Diameter Specifications (TS 4-26 01107)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
- Camshaft Timing Sprocket Bolt And Crankcase Bolt (TS 4-24 07196)
- Crankshaft Timing Belt Pulley Bolt (TS 4-25 07196)
- Crankshaft Timing Belt Pulley Bolt Tightening Torque (TS 4-23 07196)
- Modification Of Supplementary Service Manual (TS 7-08 04126)
Mechanical - Hydraulic
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Brake Noise Characteristics During Normal Operation (TS_01_10265)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Overdrive Unit
- Modification Of Automatic Transmission (TS 3-26 01126)
Paint & Coatings
- 1989-98 Paint Codes Identification Information (TS 1-02 10137(R))
- UNDERHOOD (Primer) Color Codes (TS 008 10137(R))
- Paint Codes & Identification Plate Location (TS 1-02 12136(R))
- Paint Protection - Wrap Guard Plastic Paint Protect (TS 017 06076)
- UNDERHOOD Primer Codes (TS 008 01238(R))
Passive Restraints
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Rear Suspension
- Safety Recall Campaign W2 Front Strut Reinforcement (TS 03-01 03030)
- Strut Tower Bar Bolts & Nuts Tightening Torque (TS 1-12 07117)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Restraints Control Systems
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- Essential Special Tools - Air Bag Load Tool (TS 012 09145(R))
Starter
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
Steering Column
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Steering Control Systems
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
Steering Gear
- Upper Boot For Lower Steering Shaft - New Part Avail (TS 3-29 10256)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Steering Linkage
- Upper Boot For Lower Steering Shaft - New Part Avail (TS 3-29 10256)
- Automatic Free Wheel Hub Modification (TS 5-09 10046)
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
- Wheel Spindle Modification - Front (TS 5-08 05246)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Suspension Control Systems
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
System
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Amendment Of Scan Tool Data (TS 7-09 04018)
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Addition Of Throttle Position Sensor (TS 4-28 09197)
- Vibration Noise At 2100-2300 Rpm Catalytic Converter (TS 4-27 04117)
- Modification Of Torque For Throttle Body Bolt/Nut (TS 4-25 12276)
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))
- TCC Relay Control System Diag - ECM Modification (TS 3-25 05176(R))
- Tech 1-A Cartridges - Models & Special Tools (TS 002 02236(R))
- OBD II - Non Vehicle Induced Faults (TS 015 12125)
- Modification In Duty Cycle Adjustment Procedure (TS 4-29 01098)
Towing
- Manual Free Wheel Hub Assembly, Recreational Towing (TS 5-06 03016(R))
Transfer Case
- Transfer Case Bind-Up - Driveline Pressure Release (TS 3-27 02096)
- Transfer Case Bind-Up (TS 3-02 02096(R))
Transmission Control Systems
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- Tech 1-A Cartridges & Replacement Operator's Manual (TS 002 10247(R))
- Tech 1-A Cartridges: Vehicle Applications (TS 002 10116(R))
- Transfer Case Bind-Up (TS 3-02 02096(R))
Wheel Hubs
- Automatic Free Wheel Hub Modification (TS 5-09 10046)
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
Wheels & Tire System
- Automatic Free Wheel Hub Modification (TS 5-09 10046)
- Front Wheel Hub & Front Sensor Rotor Mods For Abs (TS 3-28 09276)
- Wheel Spindle Modification - Front (TS 5-08 05246)
- Squeaking Or Clunking Noise From Front End Area (TS 1-05 01098(R))
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Tech-1A Adapter For 16 Pin Data Link Connector (DLC) (TS 016 07169(R))