Technical Service Bulletins

A/C Compressor
- Air Conditioning Compressor Noise Upon Initial Operation (SI-0011)
Accessories & Equipment
- Pass-Thru Reprogramming Software Version 1.8.3.0 (TS 04 11106R)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Accessories Control Systems
- BCM Replacement Precautions (TS 04 04277)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
Air Bag, SRS
- Airbag Light On DTC B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (TS 05 12099)
- Airbag Light On, With DTC B0081 Symptom Code "0F" (Passenger Presence System Erratic) (TS 03 01108R)
Anti-Theft Systems
- Remote Keyless Entry (RKE) Inoperative, Poor Range, Tire Pressure Monitor (TPM) Message Displayed (TS 28 08147)
Automatic Trans
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 04022R2)
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 12200)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Axle Shafts
- Front Axle Clicking Noise When Turning At Temps Below 15° F (TS 09 01238)
Body Electrical
- Airbag Light On DTC B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (TS 05 12099)
Cooling System (Mechanical)
- Check Engine Light "On", DTC P0128 (Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature) -Outside Temperatures Below Freezing (TS 24 02118)
- Correct Coolant Usage (TS 06 12086)
- Water Pump Leak (TS 06 03296)
Engine Control Systems
- Timing Chain Service Kit For Specific DTC (P0008, P0009, P0016, P0017, P0018, And/Or P0019) (SI-0012R)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- VIN # Registration After ECM Replacement (TS 04 10214)
Entertainment Systems
- Navigation Radio Intermittently Displays Blank/Black Screen, Map Disc Read Errors, Has Features Not Accessible While Driving, Navigation Radio Resets Upon Start-Up. (TS 40 09029)
- Radio Volume Fluctuation, Excessive Static, Weak Reception On Medium Strength Fm Stations (TS 38 08158)
- Intermittent Radio/DVD/Navigation Screen Operation With Possible DTCS Stored (TS 35 06118)
- Radio Volume Fluctuation, Excessive Static, Weak Reception On Medium Strength FM Stations (Reprogram Radio) (08-08-44-005A)
Exterior Body Panels
- Special Coverage Extension - Campaign "ZC"; Fuel Odor Or Spotting On The Ground (TS 27 07313)
Exterior Lights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
- Trailer Turn Signal And Stop Lamps Inoperative Or Stay On After Installing Accessory Trailer Hitch (TS 39 08258)
- Windshield Wipers Work On One Speed Only Or Controls On Turn Signal / MULTIFUNCTION Lever Are Inoperative (TS 29 09127)
Front Suspension
- Inspection And Maintenance Reminder Lower Arm Ball Joint (TS 01 11298)
Fuel System
- Special Coverage Extension - Campaign "ZC"; Fuel Odor Or Spotting On The Ground (TS 27 07313)
- XL7 Fuel Tank Filler Neck (Inlet Control Valve) Inspection (Campaign 99-Kt) (TS 18 03307R2)
Gauges & Instrument Panels
- Oil Life Reset Procedure Does Not Function As Expected (TS 07 07037)
Headlights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
Identification
- VIN # Registration After ECM Replacement (TS 04 10214)
Infotainment
- Navigation Radio Intermittently Displays Blank/Black Screen, Map Disc Read Errors, Has Features Not Accessible While Driving, Navigation Radio Resets Upon Start-Up. (TS 40 09029)
- Intermittent Radio/DVD/Navigation Screen Operation With Possible DTCS Stored (TS 35 06118)
- Navigation (NAV) System Start Up Screen Says DELPHI (TS 26 07037)
Interior/Exterior Trim
- Technician/Vehicle Owner "Best Practices": Inspecting, Removing, And Installing Floor Mats In SUZUKI Vehicles (TS 03 07210)
- Front Roof Rail Caps Are Lifting (TS 22 12187R)
- The Carpet Is Wet At The Front Driver And/Or Passenger Floor (TS 31 11167)
- Front Roof Rail Caps Are Lifting (TS 22 01257)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Lubrication System
- Internal Engine Noise And/Or Damage After Oil Filter Replacement (TS 25 03211)
- Oil Leak Identification (TS 07 07018)
- Approved Engine Oil For The XL7 (TS 08 01288R)
- Approved Engine Oil For The XL7 (TS 08 07037)
- Oil Life Reset Procedure Does Not Function As Expected (TS 07 07037)
Manual Steering
- Required Power Steering Fluid For The XL7 (TS 03 03209R)
- Required Power Steering Fluid For The XL7 (TS 03 11178)
Manual Trans
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical
- Timing Chain Service Kit For Specific DTC (P0008, P0009, P0016, P0017, P0018, And/Or P0019) (SI-0012R)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Internal Engine Noise And/Or Damage After Oil Filter Replacement (TS 25 03211)
- Random Knock Or Thumping Noise From Engine Area (TS 25 07028)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical - Hydraulic
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Restraints Control Systems
- Airbag Light On DTC B0012, B0013, B0014, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (TS 05 12099)
- Airbag Light On, DTC B1000 Set (Reprogram Passenger Presence System (PPS) Module) (08-09-41-004)
- Airbag Light On, With DTC B0081 Symptom Code "0F" (Passenger Presence System Erratic) (TS 03 01108R)
Seats
- Airbag Light On, With DTC B0081 Symptom Code "0F" (Passenger Presence System Erratic) (TS 03 01108R)
Starter
- Battery Jumping Procedure Notice (TS 09 10038)
Steering Column Switches
- Loud Click Clack With No Audio, Strange Noises When Using Turn Signals, Example: Cracking, Buzzing, Alarm Noises Etc. (TS 33 02088R)
Steering Gear
- Required Power Steering Fluid For The XL7 (TS 03 11178)
Suspension Control Systems
- Remote Keyless Entry (RKE) Inoperative, Poor Range, Tire Pressure Monitor (TPM) Message Displayed (TS 28 08147)
System
- Timing Chain Service Kit For Specific DTC (P0008, P0009, P0016, P0017, P0018, And/Or P0019) (SI-0012R)
- Check Engine Light "On", DTC P0128 (Engine Coolant Temperature (ECT) Below Thermostat Regulating Temperature) -Outside Temperatures Below Freezing (TS 24 02118)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
Towing
- Trailer Turn Signal And Stop Lamps Inoperative Or Stay On After Installing Accessory Trailer Hitch (TS 39 08258)
Transfer Case
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Automatic Transmission Fluid Leak at Transfer Case Weep Hole (Replace Front Wheel Drive Intermediate (Inner) Shaft Seal) (08-04-21-002A)
- Automatic Transmission Fluid Leak From Transfer Case (TS 10 04048)
Transmission Control Systems
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- VIN # Registration After ECM Replacement (TS 04 10214)
Window Motors & Regulators
- Safety Campaign "Kw" Stationary Glass Replacement (TS 25 06147)
Wiper/Washer Systems
- Windshield Wipers Work On One Speed Only Or Controls On Turn Signal / MULTIFUNCTION Lever Are Inoperative (TS 29 09127)