Section 2 (Diagnosis & Overhaul)
WARNING: This page is about a different variant/trim than selected.
- Automatic Transmission
- Precautions
- General Description
- Automatic Transmission Construction
- Clutch/Brake Functions of Automatic Transmission
- Table of A/T System Component Operation
- Electronic Shift Control System Description
- Electronic Shift Control System Wiring Diagram For J20 engine model
- Fail Safe Function
- Change Mechanism
- Operation of Shift Solenoids and TCC Solenoid
- Brake Interlock System Description
- Automatic Transmission Diagnosis General Description
- On-Board Diagnostic System Description
- 2 Driving Cycle Detection Logic
- Pending Diagnostic Trouble Codes
- Freeze Frame Data
- Schematic and Routing Diagram
- Diagnostic Information and Procedures
- A/T System Check
- Notes
- System Check Step Description
- Step 1: Customer complaint analysis
- Step 2: Diagnostic Trouble Codes/freeze frame data check, record and clearance
- Step 3: Visual Inspection
- Step 4: Visual inspection
- Step 5: Trouble symptom confirmation
- Step 6: Rechecking and record of Diagnostic Trouble Codes / freeze frame data
- Step 7: Rechecking and record of Diagnostic Trouble Codes/ freeze frame data
- Step 8: A/T basic check and trouble diagnosis group
- Step 9: Diagnostic Trouble Codes flow
- Step 10: Check for intermittent problem
- Step 11: Final confirmation test
- Malfunction Indicator Lamp (MIL) Check
- "O/D OFF" Lamp Operation Check
- "POWER" Lamp Operation Check
- Diagnostic Trouble Codes Table
- Diagnostic Trouble Codes Check
- Diagnostic Trouble Codes Clearance
- Fail Safe Table
- Scan Tool Data
- Visual Inspection
- A/T Basic Check
- Line Pressure Test
- Stall Test
- Road Test
- Manual Road Test
- Time Lag Test
- Engine Brake Test
- "P" Range Test
- No TCC Lock-Up
- No Gear Shift to O/D
- "O/D OFF" Light Does Not Light at Ignition Switch ON but Engine Starts Up
- "O/D OFF" Light Comes ON Steadily
- "POWER" Light Does Not Light at Ignition Switch ON but Engine Starts Up
- "POWER" Light Comes ON Steadily
- DTC P0705, P0707: Transmission Range Sensor Circuit Malfunction (PRNDL Input) & Transmission Range Sensor Circuit Low Input
- DTC P0717: Input/Turbine Speed Sensor Circuit No Signal
- DTC P0722: Output Speed Sensor Circuit No Signal
- DTC P0741, P0742: TCC (Lock-Up) Solenoid Valve Performance or Stuck OFF/ON
- DTC P2769: TCC (Lock-Up) Circuit Low
- DTC P2770: TCC (Lock-Up) Circuit High
- DTC P0751, P0752, P0756, P0757: Shift Solenoid Valve A & B (#1 & 2) Performance or Stuck OFF/ON
- DTC P0973, P0976: Shift Solenoid A & B (#1 & 2) Control Circuit Low
- DTC P0974, P0977: Shift Solenoid A & B (#1 & 2) Control Circuit High
- DTC P1740: Cruise Control Signal Circuit
- DTC P1875: "4WD LOW" Switch Circuit Malfunction
- Inspection of PCM and Its Circuit
- Brake Interlock System Inspection
- Shift Lock (Solenoid) Manual Release System Inspection
- Torque Converter Diagnosis
- A/T System Check
- Repair Instructions
- A/T Fluid Level Check
- A/T Fluid Change
- A/T Throttle Cable Adjustment
- Manual Selector Assembly Components
- Manual Selector Assembly Removal and Installation
- Manual Selector Assembly Inspection
- Select Cable Components
- Select Cable Adjustment
- Key Interlock Cable Removal and Installation
- Transmission Range Switch (Sensor) Inspection
- O/D Cut Switch Inspection
- Power / Normal Change Switch Inspection
- VSS (Speedometer) Drive Gear and Sensor Rotor Removal and Installation (for 2WD Vehicle)
- A/T (Output) Speed Sensor Inspection
- "4WD LOW" Switch Inspection
- Oil Cooler Hose and Pipes Removal and Installation
- Extension Case Oil Seal Removal and Installation (for 2WD Vehicle)
- Extension Case Removal and Installation (for 2WD Vehicle)
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) On-Vehicle Inspection
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) Removal and Installation
- Solenoid Valves (Shift Solenoid Valves and TCC Solenoid Valve) Operation Check
- Automatic Transmission (with Transfer If Equipped) Dismounting and Remounting
- Automatic Transmission Unit Disassembly
- Oil Pump Components
- Oil Pump Disassembly and Assembly
- Oil Pump Inspection
- Overdrive (Planetary Gear Side) Components
- Overdrive (Planetary Gear Side) Disassembly and Assembly
- Overdrive (Planetary Gear Side) Inspection
- Overdrive (Case Side) Components
- Overdrive (Case Side) Disassembly and Assembly
- Forward Clutch Components
- Forward Clutch Disassembly and Assembly
- Forward Clutch Inspection
- Direct Clutch Components
- Direct Clutch Disassembly and Assembly
- Direct Clutch Inspection
- Center Support Disassembly and Assembly
- Planetary Gears and Output Shaft Components
- Planetary Gears and Output Shaft Disassembly and Assembly
- Valve Body Assembly Components
- Valve Body Assembly Disassembly and Assembly
- Front Upper Valve Body Components
- Front Upper Valve Body Disassembly and Assembly
- Rear Upper Valve Body Components
- Rear Upper Valve Body Disassembly and Assembly
- Lower Valve Body Components
- Lower Valve Body Disassembly and Assembly
- Automatic Transmission Unit Assembly
- Specifications
- Special Tools and Equipment