Technical Service Bulletins

A/C Compressor
- 87-18-06 - Air Conditioning, Cleaning Of The Refrigerant Circuit (U.S. Only) (GROUP 87, NO. 18-06)
- Air Conditioning Does Not Operate (TT 87-10-05)
- A/C Compressor Inoperative, DTC 00445 Is Stored In DTC Memory (GROUP 87, NO. 07-15)
- A/C Compressor Shut Off Codes (TT 87-07-93)
- A/C Compressor Inoperative, DTC 00445 Is Stored In DTC Memory (GROUP 87, NO. 03-02)
Accessories & Equipment
- 17-19-01 - VOLKSWAGEN Engine Oil Quality Standards (U.S. Only) (GROUP 17, NO. 19-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- New Vas 6161 Battery Tester (TT 27-10-02)
Accessories Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- 27-15-03 - Battery, Discharged, Diagnosis For Excessive Static Current Draw (GROUP 27, NO. 15-03)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Radio & External Media Device Overview (GROUP 91, NO. 10-25)
- Trailer Hitch Installation (TT 66-10-02)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Instrument Cluster Noises (GROUP 68, NO. 08-03)
- Door, Cannot Be Locked With Exterior Door Handle Button; "Shift To Park" Displayed On Instrument Cluster (GROUP 57, NO. 08-07)
- Instrument Cluster, Clock Runs Too Fast (GROUP 90, NO. 08-02)
- Battery Discharged, Low Voltage Faults, Instrument Cluster Display Shows Low Voltage (TT 27-08-01)
- Capacitive Discharge Recommendation (TT 96-08-02)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Mileage Adaptation On New Clusters (TT 90-08-01)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Windshield Wiper Motor, Sets DTC 01305 Infotainment Data Bus Faulty (GROUP 92, NO. 07-04)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Multi-Function Trip Computer, Accuracy Concerns With Average Trip Fuel Consumption Calculation (GROUP 90, NO. 07-02)
- Module, Vehicle Position Recognition Control -J603-, Diagnosis (GROUP 91, NO. 07-03)
- Roof Display For Compass, Adapting To Stay On With Ignition (GROUP 91, NO. 98-02)
- Generator, Insufficient Output When Equipped With Hid/Bi-Xenon Headlamps And/Or Air Suspension (GROUP 27, NO. 07-01)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Trailer Lights Inoperative, Update Programming (Flashing) Trailer Control Module (GROUP 01, NO. 05-12)
- Update Programming (Flashing) Control Module For Towing Sensor (J345) To Accept 7-Pin To 4-Pin Adapter (GROUP 01, NO. 03-07)
- Roof Display For Compass, Adapting To Stay On With Ignition (GROUP 91, NO. 03-01)
Air Bag, SRS
- 69-19-01 - Airbag/Pyrotechnic Safety Belt Deployment Inquiries (U.S. Only) (GROUP 69, NO. 97-07)
- All Models - Air Bag Module Replacement/Testing (CTT 69-08-01)
- Air Bag Module Color Coding Tip (TT 69-09-02)
- Module, Airbag, Color Code Identification And Coding (GROUP 69, NO. 08-04)
- Air Bag Module Replacement/Testing (TT 69-08-01)
- Advanced Airbag System Description, Passenger Side Airbag (GROUP 69, NO. 07-01)
- Airbag Coding (TT 69-06-35)
- Side Airbag Igniter, Diagnostic Trouble Code(S) (DTCS) Stored In DTC Memory (GROUP 69, NO. 05-02)
- Passenger Occupant Detection System (Pods) Fault (GROUP 69, NO. 04-03)
Anti-Lock Brakes
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Drivetrain Binding/Tires Scrubbing During Low Speed Maneuvering, Esp Light In Instrument Cluster On Or Flashing (GROUP 39, NO. 04-02)
- Active Wheel Speed Sensor Diagnosis (TT 45-07-58)
Anti-Theft Systems
- Alarm Goes Off When Unlocking Door With Key Cylinder (TT 57-12-02)
- Flip Key - Key Blade Sticks Or Binds When Opening Or Closing (TT 57-13-02)
- Access/Start Module Fault 00183 "Interior Access/Start Authorization Antenna 1-R138" Diagnosis Tip (TT 96-12-08)
- Steering Column Lock Replacement (TT 96-11-09)
- Immobilizer Adaptation (TT 96-11-08)
- Immobilizer 2, 3, Or 4 - Key Adaptation Warning (TT 96-11-07)
- Immobilizer Systems (TT 96-10-07)
- KESSY Max System - Rear Door Adaption For KESSY Vehicles (TT 96-10-04)
- Alarm Source Codes (TT 57-10-05)
- Immobilizer Active Intermittently (GROUP 96, NO. 09-03)
- Key Remote, Emblem (Sign) Damaged (GROUP 57, NO. 08-12)
- Door, Cannot Be Locked With Exterior Door Handle Button; "Shift To Park" Displayed On Instrument Cluster (GROUP 57, NO. 08-07)
- "Several Key's Found" Message Displayed On Instrument Cluster (GROUP 57, NO. 08-04)
- KESSY Max System - Antenna Test Procedure (TT 96-08-04)
- Door, Front Or Rear Inner Release Handle Remains In Open Position When Exiting The Vehicle (GROUP 57, NO. 07-06)
- Easy Entry Function - Steering Wheel Will Not Move Down (TT 72-07-15)
- Front Door Scrapes Fender When Opening During PDI (TT 57-07-26)
- Immobilizer Adaptation When Replacing The ECM (TT 96-07-42)
- Convenience Open/Close Feature Inoperative (TT 64-06-93)
- Flashing Door Led (TT 57-06-95)
- MFI Displays "Key Not Found" (TT 57-06-83)
- Steering Column Replacing (TT 96-06-61)
- Vehicle Will Not Crank (TT 96-06-94)
- Folding Key Radio Remote Control, Functions Only At Close Range (GROUP 57, NO. 05-03)
- Exterior Door Handle, Remains In Open Position (GROUP 57, NO. 05-02)
- Radio, Anti-Theft Radio Security Code Retrieval Procedures (GROUP 91, NO. 05-02)
- Immobilizer, 7-Digit Pins Beginning With 0 Are Not Accepted By Control Modules (GROUP 01, NO. 04-21)
- Folding Key Radio Remote Control, Functions Only At Close Range (GROUP 57, NO. 04-04)
- Remote Control Key Transmitter, Programming To A Driver Seat Memory Position Button (GROUP 57, NO. 03-04)
- Alarm Sounds If Trailer Wiring Is Disconnected After Anti-Theft Alarm Is Activated (GROUP 57, NO. 03-02)
Automatic Trans
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- 09D Transmission - Design Change (TT 37-09-04)
- Gearbox DTCS P0753 (00258) Solenoid Valve N88 Open / Short (TT 37-06-63)
- Transmission Replacements (TT 37-08-01)
- Update Programming (Flashing) Transmission Control Module (TCM) For Harsh Shifting (PT01-07-05)
- Transmission, "PRNDS" Indicator Illuminated In Instrument Cluster (GROUP 38, NO. 07-01)
- Transmission Fluid (TT 38-07-97)
- AISIN (09D, 09G And 09M) Transmissions, Valve Body Replacement (TT 38-06-26)
- Shift Lever Button Sticking (TT 37-06-55)
- Transmission Code Identification (TT 37-06-12)
- Automatic Transmission, Repairing (GROUP 37, NO. 05-01)
- Update Programming (Flashing) Transmission Control Module (TCM) For Harsh Shifting (GROUP 01, NO. 04-13)
Auxiliary Emission Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (TT 97-14-02)
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Diagnostic Connector - No ECM Communication (GROUP 97, NO. 12-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- 5.0L TDI Engine - Engine Control Module Replacement (TT 23-11-01)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- EVAP System Functional Test (TT 20-09-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Mil On, Glow Plug Faults Stored In ECM, BOSCH Glow Plug System Only (GROUP 01, NO. 08-33)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Catalytic Converter Studs, Broken (GROUP 26, NO. 08-01)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (GROUP 01, NO. 08-11)
- Control Module Software Updates (TT 01-08-01)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Engine Control Module (ECM), Do Not Replace For These Diagnostic Trouble Codes (DTCS) (GROUP 01, NO. 07-54)
- Evaporative Emissions (EVAP) System, Checking Using The KLI 9210 EVAP System Tester (GROUP 20, NO. 07-10)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (PT01-07-52)
- Engine Control Module, Additional DTCS Programmed For Same Condition (GROUP 01, NO. 07-34)
- Customer States Rough "Idle" (GROUP 01, NO. 07-32)
- Customer States Rough Idle (PT01-07-32)
- Mil On, DTC P0420 And/Or P0430 Stored In ECM Memory (GROUP 01, NO. 07-08)
- DTC'S 00545 And 00638 Stored In DTC Memory (GROUP 01, NO. 97-13)
- ECM Replacement (TT 24-07-102)
- Fault Code 01314 - No Communication With ECM (TT 24-07-104)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Updates - Error Message "Pre Conditions Not Met / Immobilizer Is Not Enabled" (TT 01-07-72)
- Software Version Management Tip (TT 01-07-87)
- Engine Starts/Stalls Prior To Putting Vehicle Into Gear With DTC P1570 (TT 96-06-48)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Possible Engine Stumbles, And/Or Runs Rough Condition (PT01-05-15)
- Update Programming To Eliminate Possible Engine Stumble Or Rough Running Condition (Od) (GROUP 01, NO. 05-15)
- Mil Is On, DTCS P1411, P1423 Are Stored In DTC Memory (GROUP 00, NO. 05-09)
- Customer States "Vehicle Hesitates" (PT01-05-04)
- Customer States "Vehicle Hesitates" (PT01-04-15)
- Customer States "Vehicle Hesitates" (GROUP 01, NO. 04-15)
- The KLI9210 Evaporative Emissions Tester (TT 20-01-25)
- LDP System, DTC 17884 (TT 20-98-14)
Battery Management Systems
- 27-19-01 - 12VOLT Battery Testing And Charging Using MIDTRONICS Vas6161 And Or GRX3000VAS Charger (GROUP 27, NO. 19-01)
Body Electrical
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (TT 97-14-02)
- Diagnostic Connector - No ECM Communication (GROUP 97, NO. 12-01)
- Data Link Connector (DLC) Pin Assignment (TT 97-12-02)
- Wire Terminal Information (TT 97-11-01)
- Transmission Harness Replacement (TT 37-10-04)
- Printing Out Wiring Diagrams In SVG Viewer Format (TT 00-09-07)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Wiring Harness, Repairing (GROUP 97, NO. 98-03)
Body Interior
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Trailer Hitch Installation (TT 66-10-02)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Capacitive Discharge Recommendation (TT 96-08-02)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Windshield Wiper Motor, Sets DTC 01305 Infotainment Data Bus Faulty (GROUP 92, NO. 07-04)
- Multi-Function Trip Computer, Accuracy Concerns With Average Trip Fuel Consumption Calculation (GROUP 90, NO. 07-02)
- Module, Vehicle Position Recognition Control -J603-, Diagnosis (GROUP 91, NO. 07-03)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Trailer Lights Inoperative, Update Programming (Flashing) Trailer Control Module (GROUP 01, NO. 05-12)
- Update Programming (Flashing) Control Module For Towing Sensor (J345) To Accept 7-Pin To 4-Pin Adapter (GROUP 01, NO. 03-07)
Brakes Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Parking Brake Indicator Remains Illuminated (GROUP 46, NO. 08-03)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Active Wheel Speed Sensor Diagnosis (TT 45-07-58)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
Charging Systems
- 27-19-01 - 12VOLT Battery Testing And Charging Using MIDTRONICS Vas6161 And Or GRX3000VAS Charger (GROUP 27, NO. 19-01)
- 27-15-03 - Battery, Discharged, Diagnosis For Excessive Static Current Draw (GROUP 27, NO. 15-03)
- Wire Terminal Information (TT 97-11-01)
- Printing Out Wiring Diagrams In SVG Viewer Format (TT 00-09-07)
- Battery Discharged, Low Voltage Faults, Instrument Cluster Display Shows Low Voltage (TT 27-08-01)
- Generator, Appears To Be Leaking Coolant (GROUP 27, NO. 07-05)
- Wiring Harness, Repairing (GROUP 97, NO. 98-03)
- Generator, Insufficient Output When Equipped With Hid/Bi-Xenon Headlamps And/Or Air Suspension (GROUP 27, NO. 07-01)
Collision/Avoidance
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Trailer Hitch And Parking Aid - Parking Aid Deactivation! (TT 91-11-07)
- Parking Aid Control, Warning Indicator Illuminated Intermittently (GROUP 94, NO. 09-02)
Communication Devices
- MOTOROLA BLUETOOTH Installations (TT 91-07-79)
Cooling System (Mechanical)
- 19-17-01 - Identifying And Mixing VOLKSWAGEN Engine Coolants (U.S. Only) (GROUP 19, NO. 17-01)
- Generator, Appears To Be Leaking Coolant (GROUP 27, NO. 07-05)
Cruise Control Systems
- Electronic Throttle Control - Cruise Control Diagnosis Tip (TT 27-10-04)
- ECM Replacement (TT 24-07-102)
Differentials & Drive Axles
- Customer States Whining Noise From Rear Of Vehicle (GROUP 39, NO. 06-01)
- Customer States Whining Noise From Rear Of Vehicle (GROUP 39, NO. 06-02)
Electronic Steering
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
Engine Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- 27-15-03 - Battery, Discharged, Diagnosis For Excessive Static Current Draw (GROUP 27, NO. 15-03)
- 01-16-15 - Gasoline Quality (GROUP 01, NO. 16-15)
- ECM Fault P1250 "Fuel Level Too Low" Will Not Clear (CTT 20-16-02)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (TT 97-14-02)
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Diagnostic Connector - No ECM Communication (GROUP 97, NO. 12-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Diagnostic Misfire Assistance After Performing Campaign 28F3/P1 (Gasoline Engines Only) (GROUP 01, NO. 12-04)
- Control Module Coding Information (TT 01-11-05)
- 5.0L TDI Engine - Engine Control Module Replacement (TT 23-11-01)
- Main/Primary Fuel Pump Location (TT 20-11-02)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- Mil On Or Flashing, Misfire DTCS P0300-0312 Stored In ECM (GROUP 28, NO. 10-02)
- Mil On, Misfire DTCS P0300-0312 Stored After Performing Technical Bulletin 2021320 Or 28F3/P1 Campaign (GROUP 28, NO. 10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Immobilizer Active Intermittently (GROUP 96, NO. 09-03)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Mil On, Glow Plug Faults Stored In ECM, BOSCH Glow Plug System Only (GROUP 01, NO. 08-33)
- No Start After Access Start Module Replacement (GROUP 96, NO. 08-05)
- Fuel Tanks Removed From Vehicles, Neutralizing Fuel (GROUP 20, NO. 98-02)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Starter Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 08-02)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (GROUP 01, NO. 08-11)
- Main/Primary Fuel Pump Location (TT 20-07-88)
- Control Module Software Updates (TT 01-08-01)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Engine Control Module (ECM), Do Not Replace For These Diagnostic Trouble Codes (DTCS) (GROUP 01, NO. 07-54)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (PT01-07-52)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Engine Control Module, Additional DTCS Programmed For Same Condition (GROUP 01, NO. 07-34)
- Customer States Rough "Idle" (GROUP 01, NO. 07-32)
- Customer States Rough Idle (PT01-07-32)
- Mil On With DTCS P1347/17755 And P1340/17748 Stored In Memory (GROUP 15, NO. 07-03)
- Diesel Fuel, Cold Weather Conditioning For Driving At Temperatures Below 0°C (32°F) (GROUP 20, NO. 07-01)
- DTC'S 00545 And 00638 Stored In DTC Memory (GROUP 01, NO. 97-13)
- ECM Replacement (TT 24-07-102)
- Fault Code 01314 - No Communication With ECM (TT 24-07-104)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Updates - Error Message "Pre Conditions Not Met / Immobilizer Is Not Enabled" (TT 01-07-72)
- Software Version Management Tip (TT 01-07-87)
- Engine Starts/Stalls Prior To Putting Vehicle Into Gear With DTC P1570 (TT 96-06-48)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Vehicle Will Not Crank (TT 96-06-94)
- Possible Engine Stumbles, And/Or Runs Rough Condition (PT01-05-15)
- Update Programming To Eliminate Possible Engine Stumble Or Rough Running Condition (Od) (GROUP 01, NO. 05-15)
- Mil Is On, DTCS P1411, P1423 Are Stored In DTC Memory (GROUP 00, NO. 05-09)
- Flexible Fuel (Ff) Sensor -G133-, Replacing (B5) (GROUP 20, NO. 05-02)
- Customer States "Vehicle Hesitates" (PT01-05-04)
- Customer States "Vehicle Hesitates" (PT01-04-15)
- Customer States "Vehicle Hesitates" (GROUP 01, NO. 04-15)
- The KLI9210 Evaporative Emissions Tester (TT 20-01-25)
- LDP System, DTC 17884 (TT 20-98-14)
Entertainment Systems
- Improper Am Radio Station Frequencies (TT 91-11-02)
- Radio & External Media Device Overview (GROUP 91, NO. 10-25)
- Radio, Entering And Retrieving Anti-Theft (Safe) Code (GROUP 91, NO. 10-14)
- Removing Cd/DVDS From Radio When Servicing (TT 91-10-01)
- Radio Coding - Auxiliary Jack, IPOD, External Cd Changer INOP After Radio Replacement (GROUP 91, NO. 09-21)
- Improper Am Radio Station Frequencies (TT 01-08-05)
- Radio, Entering And Retrieving Anti-Theft (Safe) Code For Non PDI Vehicles (GROUP 91, NO. 07-13)
- Radio, Reception Diagnosis (GROUP 91, NO. 07-06)
- Use Of Novelty Compact Discs In Compact Disc (Cd) Players (GROUP 91, NO. 98-02)
- Loss Of Cd Changer Function When Installing An IPOD Connector (TT 91-07-45)
- XM Satellite Option, Part Supersession (TT 91-07-36)
- Customer States, Cd Not Ejecting Or Radio Face Plate Buttons Peeling (GROUP 91, NO. 06-08)
- Installing IPOD Kit On A Car With A Satellite Radio (TT 91-06-50)
- Removing Radio/NAV Units (TT 91-06-96)
- SIRIUS Satellite Radio, GCI Update (TT 91-06-38)
- Radio, Insufficient Bass Output (GROUP 91, NO. 05-05)
- Radio, Anti-Theft Radio Security Code Retrieval Procedures (GROUP 91, NO. 05-02)
- Radio, Reception Diagnosis (GROUP 91, NO. 05-01)
- Compact Disc (Cd) Player/Changer Displays Err Code 1 (GROUP 91, NO. 04-01)
- Radio, Inoperative After Replacement (GROUP 91, NO. 04-02)
Exhaust
- Exhaust Restriction Testing Tip (TT 26-09-01)
- Exhaust Heat Shield, Replacement Guidelines (GROUP 26, NO. 08-02)
- Catalytic Converter Studs, Broken (GROUP 26, NO. 08-01)
- Mil On, DTC P0420 And/Or P0430 Stored In ECM Memory (GROUP 01, NO. 07-08)
Exterior Body Panels
- 00-18-05 - Squeaks, Rattles, And Noise, Repair Materials (GROUP 00, NO. 18-05)
- Corrosion, Rear Inner Doors In Door Fold Area (GROUP 58, NO. 16-01)
- Rear Lid Does Not Open After Handle Replacement (TT 55-13-01)
- Fuel Tanks Removed From Vehicles, Neutralizing Fuel (GROUP 20, NO. 98-02)
- Water Leak Around Rear Lid, Water Staining, Rear Of Headliner (GROUP 55, NO. 08-04)
- Front Door Scrapes Fender When Opening During PDI (TT 57-07-26)
- Engine, Upper Covers Missing At PDI (GROUP 00, NO. 03-09)
Exterior Lights
- 94-19-01 - Exterior Lights, Moisture Accumulation (GROUP 94, NO. 19-01)
- Trailer Hitch Installation (TT 66-10-02)
- No Trailer Brake Lights After Trailer Hitch Installed (TT 66-09-01)
- After Repair, Headlamp Flickers At Times (TT 94-08-01)
- Tail Light Assembly, Removal Procedure (GROUP 94, NO. 06-21)
- Trailer Lights Inoperative, Update Programming (Flashing) Trailer Control Module (GROUP 01, NO. 05-12)
- Gas Discharge Headlight System, Coding To Eliminate DTC 00492 Or 01539 (GROUP 94, NO. 03-02)
- Headlights, Adjustment At Perfect Delivery Inspection (PDI) Not Required (GROUP 00, NO. 03-05)
Frames, Subframes & Crossmembers
- Trailer Hitch Installation (TT 66-10-02)
- No Trailer Brake Lights After Trailer Hitch Installed (TT 66-09-01)
- Front Bumper, Installing Front License Plate Bracket (GROUP 63, NO. 03-01)
Front Suspension
- Self-Leveling Suspension Inoperative With Error Message In MULTIFUNCTION Display (GROUP 43, NO. 11-01)
- DTC 01400 Level Control System - Control Limit Exceeded (TT 43-09-01)
- Air Suspension Pressure Valve - Suspension Dropping Down Overnight (TT 43-08-01)
- Vehicle Front Ride Height Incorrect After Stationary Period (GROUP 43, NO. 07-01)
- Air Suspension DTC 01772 (008) (TT 43-06-114)
Fuel System
- 01-16-15 - Gasoline Quality (GROUP 01, NO. 16-15)
- ECM Fault P1250 "Fuel Level Too Low" Will Not Clear (CTT 20-16-02)
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Main/Primary Fuel Pump Location (TT 20-11-02)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Fuel Tanks Removed From Vehicles, Neutralizing Fuel (GROUP 20, NO. 98-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Main/Primary Fuel Pump Location (TT 20-07-88)
- Diesel Fuel, Cold Weather Conditioning For Driving At Temperatures Below 0°C (32°F) (GROUP 20, NO. 07-01)
- Intake Manifold Runner Control Motor Adaptation (TT 24-07-32)
- Flexible Fuel (Ff) Sensor -G133-, Replacing (B5) (GROUP 20, NO. 05-02)
- The KLI9210 Evaporative Emissions Tester (TT 20-01-25)
- LDP System, DTC 17884 (TT 20-98-14)
Fuses & Circuit Breakers
- Wire Terminal Information (TT 97-11-01)
- Printing Out Wiring Diagrams In SVG Viewer Format (TT 00-09-07)
- Wiring Harness, Repairing (GROUP 97, NO. 98-03)
Gauges & Instrument Panels
- Instrument Cluster Noises (GROUP 68, NO. 08-03)
- Door, Cannot Be Locked With Exterior Door Handle Button; "Shift To Park" Displayed On Instrument Cluster (GROUP 57, NO. 08-07)
- Instrument Cluster, Clock Runs Too Fast (GROUP 90, NO. 08-02)
- Mileage Adaptation On New Clusters (TT 90-08-01)
- Multi-Function Trip Computer, Accuracy Concerns With Average Trip Fuel Consumption Calculation (GROUP 90, NO. 07-02)
- Roof Display For Compass, Adapting To Stay On With Ignition (GROUP 91, NO. 98-02)
- Roof Display For Compass, Adapting To Stay On With Ignition (GROUP 91, NO. 03-01)
Headlights
- 94-19-01 - Exterior Lights, Moisture Accumulation (GROUP 94, NO. 19-01)
- After Repair, Headlamp Flickers At Times (TT 94-08-01)
- Gas Discharge Headlight System, Coding To Eliminate DTC 00492 Or 01539 (GROUP 94, NO. 03-02)
- Headlights, Adjustment At Perfect Delivery Inspection (PDI) Not Required (GROUP 00, NO. 03-05)
HVAC Control Systems
- 87-18-12 - HVAC, Unpleasant Odor (GROUP 87, NO. 99-01)
- 87-18-06 - Air Conditioning, Cleaning Of The Refrigerant Circuit (U.S. Only) (GROUP 87, NO. 18-06)
- Air Conditioning Does Not Operate (TT 87-10-05)
- Vas 6338/1 A/C Flushing Tool Adapters (TT 87-09-08)
- Inspection Of Receiver-Drier Desiccant Cartridge Before A/C System Flush (TT 87-09-06)
- Heater, Floor Vent Airflow Poor Performance (GROUP 80, NO. 09-02)
- HVAC Unpleasant Odor (TT 87-09-01)
- ROBINAIR A/C Machine Display Appears Blank (TT 87-09-02)
- A/C Inoperative, Evaporator Temperature Sensor -G308- Damaged Or Dislodged (GROUP 87, NO. 08-02)
- A/C Compressor Inoperative, DTC 00445 Is Stored In DTC Memory (GROUP 87, NO. 07-15)
- HVAC, Ticking Noise Behind Dash Panel Or Center Console (GROUP 87, NO. 07-06)
- Heating And Ventilation Controls, Replacing Fresh Air Control Lever Light -L16- (GROUP 85, NO. 99-02)
- Windshield, Condensation On Exterior Lower Center During Warm/Humid Weather Conditions (GROUP 87, NO. 07-01)
- A/C Blows Colder In One Zone (TT 87-07-95)
- A/C Compressor Shut Off Codes (TT 87-07-93)
- Windshield, Condensation On Exterior Lower Center During Warm/Humid Weather Conditions (GROUP 87, NO. 04-01)
- A/C Compressor Inoperative, DTC 00445 Is Stored In DTC Memory (GROUP 87, NO. 03-02)
Identification
- Vehicle Identification Number (VIN) Plates, Safety Certification Labels, Ordering Procedures (GROUP 00, NO. 07-08)
- Transmission Code Identification (TT 37-06-12)
Ignition Switch/Steering Lock
- Flip Key - Key Blade Sticks Or Binds When Opening Or Closing (TT 57-13-02)
- Electronic Steering Column Lock (ESCL) Replacement (TT 96-12-04)
- Steering Column Lock Replacement (TT 96-11-09)
- Manual Rotation Of Ignition Switch During Lock Cylinder Or Housing Replacement (TT 28-10-01)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Key Remote, Emblem (Sign) Damaged (GROUP 57, NO. 08-12)
- Starter Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 08-02)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Ignition Key, Emergency Release Revision (GROUP 94, NO. 06-22)
Ignition System
- Diagnostic Misfire Assistance After Performing Campaign 28F3/P1 (Gasoline Engines Only) (GROUP 01, NO. 12-04)
- Mil On Or Flashing, Misfire DTCS P0300-0312 Stored In ECM (GROUP 28, NO. 10-02)
- Mil On, Misfire DTCS P0300-0312 Stored After Performing Technical Bulletin 2021320 Or 28F3/P1 Campaign (GROUP 28, NO. 10-01)
- Mil On, Glow Plug Faults Stored In ECM, BOSCH Glow Plug System Only (GROUP 01, NO. 08-33)
Infotainment
- Map Information Overview (GROUP 91, NO. 12-05)
- Radio & External Media Device Overview (GROUP 91, NO. 10-25)
- BOSCH Navigation Radio Repair Program (GROUP 91, NO. 10-07)
- Removing Cd/DVDS From Radio When Servicing (TT 91-10-01)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- KESSY Max System - Antenna Test Procedure (TT 96-08-04)
- Radio, Reception Diagnosis (GROUP 91, NO. 07-06)
- Module, Vehicle Position Recognition Control -J603-, Diagnosis (GROUP 91, NO. 07-03)
- Loss Of Cd Changer Function When Installing An IPOD Connector (TT 91-07-45)
- Removing Radio/NAV Units (TT 91-06-96)
- Folding Key Radio Remote Control, Functions Only At Close Range (GROUP 57, NO. 05-03)
- Radio, Reception Diagnosis (GROUP 91, NO. 05-01)
- Folding Key Radio Remote Control, Functions Only At Close Range (GROUP 57, NO. 04-04)
Interior/Exterior Trim
- 00-18-05 - Squeaks, Rattles, And Noise, Repair Materials (GROUP 00, NO. 18-05)
- Rear Cup Holder Replacement (GROUP 68, NO. 09-01)
- Interior, Cleaning Tips For Fabrics, Vinyls And Plastics (GROUP 70, NO. 99-01)
- Water Leak Around Rear Lid, Water Staining, Rear Of Headliner (GROUP 55, NO. 08-04)
- Interior, Cleaning Tips For Leather Upholstery (GROUP 70, NO. 99-02)
- Exhaust Heat Shield, Replacement Guidelines (GROUP 26, NO. 08-02)
- Instrument Cluster Noises (GROUP 68, NO. 08-03)
- Vehicle Inspection, Protection Removal And Detailing Information (GROUP 64, NO. 99-03)
- Front Door Panel, Vinyl Peeling Away Near Door Glass (GROUP 70, NO. 03-03)
- Rear Seat Armrest, Increasing CUPHOLDER Retention (GROUP 68, NO. 03-02)
- Front Bumper, Installing Front License Plate Bracket (GROUP 63, NO. 03-01)
- Rear Seat Armrest Lid, Disengaged From Armrest (GROUP 68, NO. 03-01)
Interior/Illumination Lights
- Heating And Ventilation Controls, Replacing Fresh Air Control Lever Light -L16- (GROUP 85, NO. 99-02)
Lubrication System
- 17-19-01 - VOLKSWAGEN Engine Oil Quality Standards (U.S. Only) (GROUP 17, NO. 19-01)
- 17-18-06 - Oil Consumption Measurement (GROUP 17, NO. 18-06)
- Engine Oil, VOLKSWAGEN Oil Quality Standard VW 505 01 Requirement (GROUP 17, NO. 07-06)
- Oil Pan Drain Plug, Cleaning Threads On Plug And Oil Pan When Changing Oil (GROUP 17, NO. 07-05)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
Mechanical
- 17-19-01 - VOLKSWAGEN Engine Oil Quality Standards (U.S. Only) (GROUP 17, NO. 19-01)
- 17-18-06 - Oil Consumption Measurement (GROUP 17, NO. 18-06)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Engine Oil, VOLKSWAGEN Oil Quality Standard VW 505 01 Requirement (GROUP 17, NO. 07-06)
- Oil Pan Drain Plug, Cleaning Threads On Plug And Oil Pan When Changing Oil (GROUP 17, NO. 07-05)
- Mil On With DTCS P1347/17755 And P1340/17748 Stored In Memory (GROUP 15, NO. 07-03)
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- Intake Manifold Runner Control Motor Adaptation (TT 24-07-32)
- VR6 Engine - Upper Timing Chain Noise (TT 15-07-75)
- All Model Year Engines With Adjustable Cam Timing - Knocking Noise From Chain TENSIONER/Adjuster (TT 15-06-106)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
Mirrors
- Heated Mirror, Seats And Steering Wheel, Component Operation (TT 64-07-38)
- Exterior Rear View Mirror, Wind Noise Above 50 Mph (GROUP 66, NO. 05-01)
Paint & Coatings
- 00-17-06 - Removing Paint Contaminants From Exterior Paint (GROUP 00, NO. 17-06)
- Paint Finish, Reducing Swirl Marks And Fine Scratches (V501205)
- Tire Dressing For Vehicle Detailing (TT 50-14-01)
- Technical Bulletin Materials / 3M Distribution Centers (TT 00-09-03)
- Paint Finish, Removing Industrial Fallout (GROUP 50, NO. 93-01)
- Vehicle Inspection, Protection Removal And Detailing Information (GROUP 64, NO. 99-03)
Parking Brake System
- Parking Brake Indicator Remains Illuminated (GROUP 46, NO. 08-03)
Passive Restraints
- 69-19-01 - Airbag/Pyrotechnic Safety Belt Deployment Inquiries (U.S. Only) (GROUP 69, NO. 97-07)
- Child Restraint Latch Guidance Fixture, Compliance With Federal Motor Vehicle Safety Standard 225 (USA Only) (GROUP 00, NO. 10-06)
- Child Restraint Latch Guidance Fixture, Installing At Pre-Delivery Inspection (PDI) CANADA Only (GROUP 00, NO. 10-07)
- Interior, Cleaning Tips For Fabrics, Vinyls And Plastics (GROUP 70, NO. 99-01)
- Interior, Cleaning Tips For Leather Upholstery (GROUP 70, NO. 99-02)
- Seat Backrest Rear - Noises (GROUP 72, NO. 08-02)
- Seat Back Frame Replacement (TT 72-08-01)
- Heated Mirror, Seats And Steering Wheel, Component Operation (TT 64-07-38)
- Replacing Seat Bottom Frames (TT 72-07-57)
Procedures
- 00-18-09 - Safety Related Inquiry And Reporting (GROUP 00, NO. 18-09)
Rear Suspension
- Clicking Noise From Rear End (TT 42-08-01)
- Self-Leveling Suspension Inoperative With Error Message In MULTIFUNCTION Display (GROUP 43, NO. 11-01)
- DTC 01400 Level Control System - Control Limit Exceeded (TT 43-09-01)
- Air Suspension Pressure Valve - Suspension Dropping Down Overnight (TT 43-08-01)
- Vehicle Front Ride Height Incorrect After Stationary Period (GROUP 43, NO. 07-01)
- Air Suspension DTC 01772 (008) (TT 43-06-114)
Restraints Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Air Bag Module Replacement/Testing (TT 69-08-01)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Advanced Airbag System Description, Passenger Side Airbag (GROUP 69, NO. 07-01)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Airbag Coding (TT 69-06-35)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Side Airbag Igniter, Diagnostic Trouble Code(S) (DTCS) Stored In DTC Memory (GROUP 69, NO. 05-02)
- Passenger Occupant Detection System (Pods) Fault (GROUP 69, NO. 04-03)
Seats
- Child Restraint Latch Guidance Fixture, Compliance With Federal Motor Vehicle Safety Standard 225 (USA Only) (GROUP 00, NO. 10-06)
- Child Restraint Latch Guidance Fixture, Installing At Pre-Delivery Inspection (PDI) CANADA Only (GROUP 00, NO. 10-07)
- Interior, Cleaning Tips For Fabrics, Vinyls And Plastics (GROUP 70, NO. 99-01)
- Interior, Cleaning Tips For Leather Upholstery (GROUP 70, NO. 99-02)
- Seat Backrest Rear - Noises (GROUP 72, NO. 08-02)
- Seat Back Frame Replacement (TT 72-08-01)
- Heated Mirror, Seats And Steering Wheel, Component Operation (TT 64-07-38)
- Replacing Seat Bottom Frames (TT 72-07-57)
Starter
- 27-19-01 - 12VOLT Battery Testing And Charging Using MIDTRONICS Vas6161 And Or GRX3000VAS Charger (GROUP 27, NO. 19-01)
- 27-15-03 - Battery, Discharged, Diagnosis For Excessive Static Current Draw (GROUP 27, NO. 15-03)
- KESSY Max System - Rear Door Adaption For KESSY Vehicles (TT 96-10-04)
- New Vas 6161 Battery Tester (TT 27-10-02)
- Immobilizer Active Intermittently (GROUP 96, NO. 09-03)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- No Start After Access Start Module Replacement (GROUP 96, NO. 08-05)
- Starter Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 08-02)
- Battery Discharged, Low Voltage Faults, Instrument Cluster Display Shows Low Voltage (TT 27-08-01)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Module, Vehicle Position Recognition Control -J603-, Diagnosis (GROUP 91, NO. 07-03)
- Battery, Testing, Charging Using MIDTRONICS MCR340V Battery Analyzer Or Incharge 940 (Inc-940) Battery Charging Station (GROUP 27, NO. 07-02)
- Generator, Insufficient Output When Equipped With Hid/Bi-Xenon Headlamps And/Or Air Suspension (GROUP 27, NO. 07-01)
- Vehicle Will Not Crank (TT 96-06-94)
- Automatic Battery Cutoff Switch (BCS), Malfunctioning Resulting In Battery Discharge (GROUP 00, NO. 04-05)
- Battery, Maintaining Charge During Repairs (GROUP 27, NO. 03-03)
- Battery, Checking Terminal Clamps For Correct Seating At Perfect Delivery Inspection (PDI) Not Required (GROUP 00, NO. 03-04)
Steering Column
- Electronic Steering Column Lock (ESCL) Replacement (TT 96-12-04)
- Steering Column Lock Replacement (TT 96-11-09)
- Easy Entry Function - Steering Wheel Will Not Move Down (TT 72-07-15)
- Heated Mirror, Seats And Steering Wheel, Component Operation (TT 64-07-38)
- Steering Column Replacing (TT 96-06-61)
- Steering Wheel, Repairing Leather Wrap (GROUP 69, NO. 04-04)
Steering Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
Sun Roof/T-Top/Convertible Top
- Water Leak, Sliding Roof (GROUP 60, NO. 07-03)
- Vehicle Inspection, Protection Removal And Detailing Information (GROUP 64, NO. 99-03)
Suspension Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Self-Leveling Suspension Inoperative With Error Message In MULTIFUNCTION Display (GROUP 43, NO. 11-01)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- TPMS Module Coding (TT 44-11-02)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- DTC 01400 Level Control System - Control Limit Exceeded (TT 43-09-01)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Tire Pressure Monitoring System (TPMS), Diagnosing (GROUP 44, NO. 08-01)
- Air Suspension Pressure Valve - Suspension Dropping Down Overnight (TT 43-08-01)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Tire Pressure Monitoring System, Warning Light Is On (GROUP 44, NO. 07-03)
- Vehicle Front Ride Height Incorrect After Stationary Period (GROUP 43, NO. 07-01)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Version Management Tip (TT 01-07-87)
- Air Suspension DTC 01772 (008) (TT 43-06-114)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Tire Pressure Monitoring System, Module Coding (Software Level 0052) (GROUP 44, NO. 04-04)
System
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- 27-15-03 - Battery, Discharged, Diagnosis For Excessive Static Current Draw (GROUP 27, NO. 15-03)
- 01-16-15 - Gasoline Quality (GROUP 01, NO. 16-15)
- ECM Fault P1250 "Fuel Level Too Low" Will Not Clear (CTT 20-16-02)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (TT 97-14-02)
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Diagnostic Connector - No ECM Communication (GROUP 97, NO. 12-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Diagnostic Misfire Assistance After Performing Campaign 28F3/P1 (Gasoline Engines Only) (GROUP 01, NO. 12-04)
- Control Module Coding Information (TT 01-11-05)
- 5.0L TDI Engine - Engine Control Module Replacement (TT 23-11-01)
- Main/Primary Fuel Pump Location (TT 20-11-02)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- Mil On Or Flashing, Misfire DTCS P0300-0312 Stored In ECM (GROUP 28, NO. 10-02)
- Mil On, Misfire DTCS P0300-0312 Stored After Performing Technical Bulletin 2021320 Or 28F3/P1 Campaign (GROUP 28, NO. 10-01)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Immobilizer Active Intermittently (GROUP 96, NO. 09-03)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Navigation Software Update Due To No Start - Battery Drain Condition (GROUP 91, NO. 09-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Mil On, Glow Plug Faults Stored In ECM, BOSCH Glow Plug System Only (GROUP 01, NO. 08-33)
- No Start After Access Start Module Replacement (GROUP 96, NO. 08-05)
- Fuel Tanks Removed From Vehicles, Neutralizing Fuel (GROUP 20, NO. 98-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Starter Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 08-02)
- Catalytic Converter Studs, Broken (GROUP 26, NO. 08-01)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (GROUP 01, NO. 08-11)
- Main/Primary Fuel Pump Location (TT 20-07-88)
- Control Module Software Updates (TT 01-08-01)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Engine Control Module (ECM), Do Not Replace For These Diagnostic Trouble Codes (DTCS) (GROUP 01, NO. 07-54)
- Evaporative Emissions (EVAP) System, Checking Using The KLI 9210 EVAP System Tester (GROUP 20, NO. 07-10)
- Update Programming, Mil On, DTCS P0420 And Or P0430 Stored In ECM Fault Memory (PT01-07-52)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Engine Control Module, Additional DTCS Programmed For Same Condition (GROUP 01, NO. 07-34)
- Customer States Rough "Idle" (GROUP 01, NO. 07-32)
- Customer States Rough Idle (PT01-07-32)
- Mil On With DTCS P1347/17755 And P1340/17748 Stored In Memory (GROUP 15, NO. 07-03)
- Mil On, DTC P0420 And/Or P0430 Stored In ECM Memory (GROUP 01, NO. 07-08)
- Diesel Fuel, Cold Weather Conditioning For Driving At Temperatures Below 0°C (32°F) (GROUP 20, NO. 07-01)
- DTC'S 00545 And 00638 Stored In DTC Memory (GROUP 01, NO. 97-13)
- ECM Replacement (TT 24-07-102)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Fault Code 01314 - No Communication With ECM (TT 24-07-104)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Intake Manifold Runner Control Motor Adaptation (TT 24-07-32)
- Software Updates - Error Message "Pre Conditions Not Met / Immobilizer Is Not Enabled" (TT 01-07-72)
- Software Version Management Tip (TT 01-07-87)
- Engine Starts/Stalls Prior To Putting Vehicle Into Gear With DTC P1570 (TT 96-06-48)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Vehicle Will Not Crank (TT 96-06-94)
- Possible Engine Stumbles, And/Or Runs Rough Condition (PT01-05-15)
- Update Programming To Eliminate Possible Engine Stumble Or Rough Running Condition (Od) (GROUP 01, NO. 05-15)
- Mil Is On, DTCS P1411, P1423 Are Stored In DTC Memory (GROUP 00, NO. 05-09)
- Flexible Fuel (Ff) Sensor -G133-, Replacing (B5) (GROUP 20, NO. 05-02)
- Customer States "Vehicle Hesitates" (PT01-05-04)
- Customer States "Vehicle Hesitates" (PT01-04-15)
- Customer States "Vehicle Hesitates" (GROUP 01, NO. 04-15)
- The KLI9210 Evaporative Emissions Tester (TT 20-01-25)
- LDP System, DTC 17884 (TT 20-98-14)
Towing
- Trailer Hitch And Parking Aid - Parking Aid Deactivation! (TT 91-11-07)
- Trailer Hitch Installation (TT 66-10-02)
- No Trailer Brake Lights After Trailer Hitch Installed (TT 66-09-01)
Towing Systems
- Trailer Hitch And Parking Aid - Parking Aid Deactivation! (TT 91-11-07)
- Trailer Hitch Installation (TT 66-10-02)
- No Trailer Brake Lights After Trailer Hitch Installed (TT 66-09-01)
- Trailer Lights Inoperative, Update Programming (Flashing) Trailer Control Module (GROUP 01, NO. 05-12)
- Update Programming (Flashing) Control Module For Towing Sensor (J345) To Accept 7-Pin To 4-Pin Adapter (GROUP 01, NO. 03-07)
Transfer Case
- Transfer Case Fin Damage Due To Removal (TT 39-06-109)
- Transfer Case, Checking/Replacement (Bn) (GROUP 34, NO. 04-02)
Transmission Control Systems
- 01-18-12 - Software Version Management (GROUP 01, NO. 18-12)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- SVM Update Instructions (TT 00-14-03)
- BLUETOOTH Disabling While Performing Module Updates (CTT 01-14-01)
- Transmission Control Module Update (CTT 37-11-01)
- Saving A GFF Log (TT 00-12-04)
- Unable To View Diagnostic (GFF) Logs With Internet Explorer 9 (TT 00-12-03)
- Control Module Coding Information (TT 01-11-05)
- GFF System Test (TT 01-11-07)
- Using Correct Vehicle Information When Performing GFF Functions (TT 00-11-06)
- Transmission Control Module Update (TT 37-11-01)
- Software Update Reference Page (TT 01-10-05)
- Software Updating Tips (TT 01-10-02)
- Initiating A Module After Coding Or Adaptation (TT 01-10-01)
- Transmission Harness Replacement (TT 37-10-04)
- GFF Diagnosis Log Tip (TT 00-10-02)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Fault 800.11 When Updating Software On-Line (TT 00-09-06)
- SVM Software Update Tip (TT 01-09-04)
- Gearbox DTCS P0753 (00258) Solenoid Valve N88 Open / Short (TT 37-06-63)
- Fault Code Index Numbers During Diagnosis (TT 01-08-02)
- Tip For Replacing A Control Module (TT 00-08-03)
- Using The 5054A Wireless Transmitter For Flash Updates (TT 01-08-04)
- Update Programming (Flashing) Transmission Control Module (TCM) For Harsh Shifting (PT01-07-05)
- Transmission, "PRNDS" Indicator Illuminated In Instrument Cluster (GROUP 38, NO. 07-01)
- DTC'S 00545 And 00638 Stored In DTC Memory (GROUP 01, NO. 97-13)
- GFF Selection "Conversion Rectifying Campaign" (TT 01-07-89)
- Software Updates - Error Message "Pre Conditions Not Met / Immobilizer Is Not Enabled" (TT 01-07-72)
- Software Version Management Tip (TT 01-07-87)
- Freeze Frame Data (TT 01-06-47)
- No Communication With Vas 5052 (TT 00-06-45)
- Sensor Checking (TT 97-06-64)
- Shift Lever Button Sticking (TT 37-06-55)
- Vas 5051B / 5052 Scan Tool - Difficulty Performing On-Line Adaptations (TT 00-06-86)
- Vas 5051B/5052 Software Changes (TT 00-06-65)
- Update Programming (Flashing) Transmission Control Module (TCM) For Harsh Shifting (GROUP 01, NO. 04-13)
Wheels & Tire System
- Tire Dressing For Vehicle Detailing (TT 50-14-01)
- TPMS Module Coding (TT 44-11-02)
- Tire Pressure Monitoring System (TPMS), Diagnosing (GROUP 44, NO. 08-01)
- Tire Pressure Monitoring System, Warning Light Is On (GROUP 44, NO. 07-03)
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Tire Pressure Monitoring System, Module Coding (Software Level 0052) (GROUP 44, NO. 04-04)
Window Motors & Regulators
- 64 Exterior Glass Cleaning (GROUP 64, NO. 17-41)
- Customer States Windshield Wipers, Streak Or Smear - CANADA Only (GROUP 92, NO. 08-03)
- Convenience Open/Close Feature Inoperative (TT 64-06-93)
- Windshield, Condensation On Exterior Lower Center During Warm/Humid Weather Conditions (GROUP 87, NO. 04-01)
- Vehicle Inspection, Protection Removal And Detailing Information (GROUP 64, NO. 99-03)
- New Vehicle Windshield, Rear And Side Glass, Scratch, Stress Crack And Distortion Survey Form (GROUP 64, NO. 99-02)
Wiper/Washer Systems
- Customer States Windshield Wipers, Streak Or Smear - CANADA Only (GROUP 92, NO. 08-03)
- Windshield Wiper Motor, Sets DTC 01305 Infotainment Data Bus Faulty (GROUP 92, NO. 07-04)
- Washer Jets (Front Or Rear), Restricted (GROUP 92, NO. 06-07)
- Customer States Windshield Wipers, Streak Or Smear (GROUP 92, NO. 06-04)
Wiring Diagrams
- Printing Out Wiring Diagrams In SVG Viewer Format (TT 00-09-07)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- 00-18-05 - Squeaks, Rattles, And Noise, Repair Materials (GROUP 00, NO. 18-05)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (CTT 97-16-01)
- Damage To Data Link Connector (DLC) From Aftermarket Devices (Cannot Communicate With Vehicle OBD System) (TT 97-14-02)
- Diagnostic Connector - No ECM Communication (GROUP 97, NO. 12-01)
- Data Link Connector (DLC) Pin Assignment (TT 97-12-02)
- Wire Terminal Information (TT 97-11-01)
- Transmission Harness Replacement (TT 37-10-04)
- Printing Out Wiring Diagrams In SVG Viewer Format (TT 00-09-07)
- Mil On, No Can Communication, Shifter Lever Will Not Come Out Of Park, No Start (GROUP 97, NO. 09-02)
- Starter, Does Not Crank, Engine Does Not Start; Key Cannot Be Removed From Ignition Switch (GROUP 27, NO. 07-06)
- Wiring Harness, Repairing (GROUP 97, NO. 98-03)