Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Anti-Theft Systems
- Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Drive Plate Installing (Revised Procedure) (GROUP 13, NO. 93-05)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Erratic Shifting - ATF Mixed With HYPOID Oil (GROUP 39, NO. 91-02)
- Final Drive Housing Cover Leakage (GROUP 39, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
- 010 Auto Trans Final Drive Housing Cover Bolt Torque (GROUP 38, NO. 89-01)
- Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Knock Sensor Supersession - New Wire Connectors (GROUP 28, NO. 90-03)
- Stall After Initial Start At High Ambient Temps. (GROUP 24, NO. 90-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- On Board Diagnosis Light On - CALIFORNIA Only (GROUP 24, NO. 89-07)
- Resetting OBD/OBD Discontinued (GROUP 90, NO. 89-02)
- Axle Shafts
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Starter Motor Does Not Engage When Hot/With 010 TRAN (GROUP 27, NO. 92-02)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Knock Sensor Supersession - New Wire Connectors (GROUP 28, NO. 90-03)
- Cold Weather Start Precautions (GROUP 24, NO. 90-04)
- Stall After Initial Start At High Ambient Temps. (GROUP 24, NO. 90-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- On Board Diagnosis Light On - CALIFORNIA Only (GROUP 24, NO. 89-07)
- Resetting OBD/OBD Discontinued (GROUP 90, NO. 89-02)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- HVAC Control Systems
- Air Conditioner Odor (TT 87-97-20)
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- A/C Drain Hose Leaking, Cleanup (GROUP 87, NO. 91-09)
- A/C Compressor Valve Plate, Head & Gasket Replacing (GROUP 87, NO. 91-06)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Locking Hubs
- Lubrication System
- Manual Steering
- Manual Trans
- 020 Trans. - Shifter Difficult To Operate (GROUP 34, NO. 98-01)
- 020 - Transmission Case Sealing (GROUP 34, NO. 97-06)
- 020 Ring & Pinion Damage Due To Chipped Reverse Gear (GROUP 34, NO. 97-05)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Universal Transmission Support 3282 (GROUP 00, NO. 93-04)
- Pressure Plate Mounting Bolts Torque Specifications (GROUP 30, NO. 92-02)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Correction To 3RD/4TH Gear Synchronizer Hub Assembly (GROUP 35, NO. 91-03)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Flanges On Remanufactured Transmissions (GROUP 40, NO. 40-90-T01)
- Magnet In Clutch Housing Secured With Sealant (GROUP 34, NO. 90-01)
- Mechanical
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Crankshaft Drive Belt Sprocket Bolt Torque Specs (GROUP 13, NO. 92-03)
- Pressure Plate Mounting Bolts Torque Specifications (GROUP 30, NO. 92-02)
- Alternator Light On, V Belt Squeals When Wet (GROUP 13, NO. 92-02)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Drive Plate Supersession, Replacing (GROUP 13, NO. 91-04)
- Engine Ticking Noises At 1800 To 3200 Rpm (GROUP 13, NO. 91-02)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- No Start - Idle Stabilizer Valve Sticking (GROUP 24, NO. 90-05)
- Crankshaft Drive Sprocket Bolt Changed (GROUP 13, NO. 90-01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- Modified Engine Oil Dipstick (GROUP 17, NO. 89-02)
- Cylinder Head Ticking Noise At 2000 Rpm (GROUP 15, NO. 89-01)
- V-Belt Squealing - Checking & Adjusting (GROUP 13, NO. 89-02)
- Fuel Injection System & Intake Valve Cleaning (GROUP 24, NO. 89-01)
- 1.8L Engine - Metallic Clicking Noise (GROUP 13, NO. 89-01)
- Mechanical - Hydraulic
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Suspension Control Systems
- System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Starter Motor Does Not Engage When Hot/With 010 TRAN (GROUP 27, NO. 92-02)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Knock Sensor Supersession - New Wire Connectors (GROUP 28, NO. 90-03)
- No Start - Idle Stabilizer Valve Sticking (GROUP 24, NO. 90-05)
- Cold Start & Warm Up Difficulties Below 10 Degrees F (GROUP 28, NO. 28-90-T01)
- Cold Weather Start Precautions (GROUP 24, NO. 90-04)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- Ignition Related Engine Miss: New Ignition Connector (GROUP 28, NO. 90-02)
- Stall After Initial Start At High Ambient Temps. (GROUP 24, NO. 90-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- On Board Diagnosis Light On - CALIFORNIA Only (GROUP 24, NO. 89-07)
- Hall Sensor Ignition Kit Parts Information (GROUP 28, NO. 89-01)
- Resetting OBD/OBD Discontinued (GROUP 90, NO. 89-02)
- Fuel Injection System & Intake Valve Cleaning (GROUP 24, NO. 89-01)
- Transfer Case
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Wheel Alignment
- Wheels & Tire System
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Rear Tire Wear - Excessive Positive Toe (GROUP 42, NO. 96-01)
- Vehicle Pulls/Drifts To One Side - Rotate Tires (GROUP 44, NO. 94-01)
- Wheels/Tires, Eliminating Vibrations - Information (GROUP 44, NO. 94-03)
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Aerosol Tire Inflator/Sealer - Flammability Hazard (GROUP 44, NO. 91-02)
- Eliminating Vibrations - Diagnosis (GROUP 44, NO. 91-01)
- Tire Rotation/Wear Diagnosis/Information (GROUP 44, NO. 90-06)
- Suspension Strut/Wheel Bearing Housing Nut Torque (GROUP 40, NO. 90-02)
- Abnormal Rear Tire Wear - New Stub Axle (GROUP 44, NO. 90-01)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)