Technical Service Bulletins: Other Variant

WARNING: This page is about the Vitara JLS, 4D Utility, 1.6, which is a different variant/trim than selected.

A/C Compressor
- Air Conditioning Compressor Noise Upon Initial Operation (SI-0011)
Accessories & Equipment
- Pass-Thru Reprogramming Software Version 1.8.3.0 (TS 04 11106R)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Accessories Control Systems
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
Anti-Theft Systems
- Dead Batteries In Keyless Entry Remote "Fobs" (TS 08-01 02250)
Automatic Trans
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 04022R2)
- Replacing And Tightening Torque Converter Bolts During Transmission Replacement (TS 01 12200)
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Servicing And Replacement Of Automatic Transmission Fluid Pipe Union Bolt And Gasket (TS 02 04277)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Auxiliary Emission Control Systems
- Service Manual Update For DTC P0420 And/Or (P0430 V6) Inspection And Troubleshooting (TS 05 11094)
- Service Manual Update (TS 10 07113)
Axle Shafts
- Transfer Case Bind-Up (TS 3-02 02096(R))
Cooling System (Mechanical)
- Water Pump Leak (TS 06 03296)
- Correct Coolant Usage (TS 04 04145R)
- Correct Coolant Usage (TS 02 01074)
- Correct Coolant Usage (TS 04 01074)
- Correct Coolant Usage (TS 01 01074)
Differentials & Drive Axles
- Front Differential Oil Seal Replacement (TS 06 05227)
- Bevel Pinion Mounting Distance (TS 03 07084)
- Oil Leakage From The Front Differential Right Side Seal (TS 07-01 10230)
- Oil Leakage From The Front Differential Right Side Seal (TS 03-01 10230)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
- Transfer Case Bind-Up (TS 3-02 02096(R))
Driveshaft & Universal Joints
- Transfer Case Bind-Up (TS 3-02 02096(R))
Engine Control Systems
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
Exhaust
- Exhaust System Noise (TS 17 03296)
- Service Manual Update For DTC P0420 And/Or (P0430 V6) Inspection And Troubleshooting (TS 05 11094)
Exterior Lights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
Frames, Subframes & Crossmembers
- Special Coverage Adjustment "PQ": Corrosion Inspection Of Front Suspension Frame (TS 05 12198)
Front Suspension
- Inspection And Maintenance Reminder Lower Arm Ball Joint (TS 01 11298)
- Special Coverage Adjustment "PQ": Corrosion Inspection Of Front Suspension Frame (TS 05 12198)
Fuel System
- Service Manual Update (TS 10 07113)
Headlights
- Moisture Accumulation Inside Headlamp And Signal Lenses (SI-0023)
Ignition Switch/Steering Lock
- Ignition Key Binds In Accessory Position (TS 03-01 11211)
Interior/Exterior Trim
- Technician/Vehicle Owner "Best Practices": Inspecting, Removing, And Installing Floor Mats In SUZUKI Vehicles (TS 03 07210)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Locking Hubs
- Transfer Case Bind-Up (TS 3-02 02096(R))
Lubrication System
- Oil Leak Identification (TS 07 07018)
- Modification Of Main Bearing Oil Clearance And The Bearing Selection Procedure (TS 14 05175)
- Correct Amount Of Engine Oil Needed To Raise Oil Level From Low Mark To Full Mark On Oil Level Dipstick (TS 09 03143)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Manual Trans
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
Mechanical
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Modification Of Main Bearing Oil Clearance And The Bearing Selection Procedure (TS_14_10285R)
- Modification Of Main Bearing Oil Clearance And The Bearing Selection Procedure (TS 14 05175)
- Service Manual Update For Resealing Front Timing Chain Cover (TS 12 01074)
- Rear Main Oil Seal Installation Tools (TS 03 05073)
- Service Manual Update On Selection Method Of The Standard Size Connecting Rod Bearing (TS 08 02103)
- Engine Tick Noise (TS 02 12112)
Mechanical - Hydraulic
- Replacement Bolts Are Not The Same Color As The Original Bolts (TS 03 03296)
- Brake Noise Characteristics During Normal Operation (TS_01_10265)
- Sealant & THREADLOCKER Cross-Reference Chart (TS 019 01098)
Restraints Control Systems
- Service Manual Update Correction - DTC, B1026 Flow Table (TS 05 03143)
System
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Service Manual Update For DTC P0420 And/Or (P0430 V6) Inspection And Troubleshooting (TS 05 11094)
- Tech 2 PCMCIA Card Re Flash Update (TS 03 10173R)
Transfer Case
- Transfer Case Bind-Up (TS 3-02 02096(R))
Transmission Control Systems
- Error Code 7156 When Attempting To Program Or Reprogram With Pass-Thru Reprogramming Software Version 1.9.0.2 (TS 06 06257)
- Electronic Control Unit (Ecu) Reprogramming Verification Procedure Using The SUZUKI SDS Tool (TS 05 10056)
- Transfer Case Bind-Up (TS 3-02 02096(R))
Window Motors & Regulators
- Front Door Window Glass Tips Forward When Closing (TS 02 08092)