LEMON Manuals
: Even more car manuals for everyone: 1960-2025
Home
>>
Volvo
>>
2005
>>
V70 Base, 2.5 59, AWD
>>
Repair and Diagnosis
>>
Transmission
>>
Manual Trans
>>
Transmission - Checking & Inspection
September 30: LEMON manuals is back up on a temporary server! Slowness is possible
Transmission - Checking & Inspection
Expand All (for easy ctrl-f)
Collapse All
Transmission
Checking internal components of the transmission
Checking shift solenoids
Checking shift solenoids
Checking the line pressure solenoid SLT, SLC1, SLC2, SLC3, SLB1 and Lock-up solenoid SLU
Checking the oil temperature sensor
Checking the input and output speed sensors for the transmission
Checking the input and output speed sensors for the transmission
Checking pressure and temperature sensor
Checking pressure and temperature sensor
Checking the oil level (AW50/51 AWD; AW55-50/51SN; 2001-2007)
Notes
Conditions
Conditions
Preparing to check the oil level
Move the gear selector through all positions. Wait in each position for approximately 3 seconds
Low level (topping up)
Top up with oil through the dipstick pipe
High level (overfilling)
Notes
Drain off oil
Checking wiring and terminals. Intermittent faults
Inspect terminals visually
Open-circuit, intermittent faults
Short-circuit to ground, intermittent faults
Short-circuit to supply voltage, intermittent faults
Loose connections (terminals)
Contact resistance and oxidation
Checking wiring and terminals. Permanent fault
Check terminals visually
Open-circuit, permanent faults
Short-circuit to ground, permanent faults
Short-circuit to supply voltage. Permanent faults
Contact resistance and oxidation
Clutch slave cylinder
Notes
Removal
Removing the gearbox
Removing the clutch cylinder
Checking the clutch cylinder and the throw-out bearing
Installation
Notes
Installing the clutch cylinder
Finishing