Overview - Right Fuel Delivery Unit/Fuel Level Sensor, AWD Vehicles

WARNING: This page is about a different car, the 2021 Volkswagen Tiguan, 2020 Volkswagen Tiguan, 2019 Volkswagen Tiguan, and 2018 Volkswagen Tiguan. However, it is still accessible from the selected car via links, so may be relevant.

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Fuel Delivery Unit
- With the Transfer Fuel Pump -G6-
- With integrated fuel filter; the fuel filter cannot be replaced separately
- Check the electric fuel pump in Guided Fault Finding using the Vehicle Diagnostic Tester.
- Removing and Installing. Refer to FUEL DELIVERY UNIT/FUEL LEVEL SENSOR, REMOVING AND INSTALLING, AWD VEHICLES .
- Fill the vehicle with at least five liters of fuel after installing
- Installation position. Refer to Fig 1.
Seal
- Always replace after removing.
- Install dry
Locking Ring
- 110 Nm
- Loosen and tighten using the Wrench - Fuel Sending Unit: T10202
Connector
- Connector Assignment. Refer to Fig 4.
- Pull on the connector to make sure it is engaged correctly and securely.
Connector
- Pull on the connector to make sure it is engaged correctly and securely.
Fuel Pump Control Module -J538-
- Check in Guided Fault Finding using the Vehicle Diagnostic Tester.
- Removing and Installing. Refer to Fuel Pump Control Module -J538-, REMOVING AND INSTALLING .
Fuel Line
- To the engine
- Do not kink
- Connector Couplings, Disconnecting and Connecting. Refer to CONNECTOR COUPLINGS, DISCONNECTING .
Fuel Gauge Sensor -G-
- Removing and Installing. Refer to Fuel Level Sensor -G-, REMOVING AND INSTALLING .
Fuel Line
- To the left side of the fuel tank
- Do not kink
- Connector Couplings, Disconnecting and Connecting. Refer to CONNECTOR COUPLINGS, DISCONNECTING .