Climatic A/C System With Manual Control Overview
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2009 Volkswagen Rabbit, 2009 Volkswagen GTI, 2008 Volkswagen Rabbit, 2008 Volkswagen R32, and 2008 Volkswagen GTI. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
Disconnect the battery before removing the components marked with **. Refer to [For transmission(s) 0A4, 02E, 09G, 02Q] Removal and Installation .
A data plate on the lock carrier indicates the refrigerant used and capacity.
- Dash Panel **
- Center Vents
- Removing and installing, refer to CENTER VENT .
- Right Side Vent
- Right Vent
- Removing and installing, refer to RIGHT OR LEFT VENT .
- "Climatic" Heating and A/C Controls With A/C Control Module -J301-
- With instrument panel interior temperature sensor -G56-.
- With Fresh Air/Recirculating Door Switch -E159-.
- With Rear Window Defogger Switch -E230-.
- With Fresh Air Blower Switch -E9-.
- With A/C Control Module -J301-.
- With Heated Driver Seat Adjuster -E94- and Heated Front Passenger Seat Adjuster -E95-.
- Removing and installing, refer to CLIMATIC A/C CONTROLS .
- Recirculation Door Motor -V113-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to RECIRCULATION DOOR MOTOR -V113- .
- Replacing, initiate Basic Setting function with Vehicle Diagnosis, Testing and Information System VAS 5051B. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Right Footwell Vent
- Removing and installing, refer to RIGHT FOOTWELL VENT .
- Fresh Air Blower -V2-
- Removing and installing, refer to FRESH AIR BLOWER -V2- .
- Fresh Air Blower Series Resistor With Fuse -N24-
- Removing and installing, refer to FRESH AIR BLOWER SERIES RESISTOR WITH FUSE -N24- .
- Heating Unit Partition
- Removing, refer to HEATING UNIT PARTITION .
- Evaporator Temperature Sensor -G308- or Evaporator Vent Temperature Sensor -G263-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.NOTE:
One or both of the component designations will appear, depending on software. The tasks are the same.
- Removing and installing, refer to EVAPORATOR TEMPERATURE SENSOR -G308- OR EVAPORATOR VENT TEMPERATURE SENSOR -G263- .
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Cap
- Only in vehicles without air guide to vent installed in center console at rear.
- Dust and Pollen Filter
- With activated charcoal filter.
- Removing and installing, refer to DUST AND POLLEN FILTER .
- Connection
- For center console air guide.
- The center console must be removed to remove it. Refer to Removal and Installation .
- Rear Channel For Right Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Rear Channel For Left Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Screw
- Quantity: 8
- Adapter For Controls
- Auxiliary Heater Heating Element -Z35-
- Only installed on vehicles with Diesel engine.
- Heater Core
- Removing and installing, refer to HEATER CORE .
- Left Footwell Vent
- Removing and installing, refer to LEFT FOOTWELL VENT .
- Temperature Regulator Door Motor -V68-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to TEMPERATURE REGULATOR DOOR MOTOR -V68- .
- Replacing, initiate Basic Setting function with Vehicle Diagnosis, Testing and Information System VAS 5051B. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Flexible Shaft
- Removing and installing, refer to FLEXIBLE AIR DISTRIBUTION SHAFT .
- Footwell Outlet Temperature Sensor -G192-
- Removing and installing, refer to FOOTWELL OUTLET TEMPERATURE SENSOR -G192- .
- Heating and A/C Unit
- Removing and installing, refer to HEATING AND A/C UNIT .
- Disassembling and assembling, refer to CLIMATIC HEATING AND A/C UNIT .
- Left Side Vent
- Center Outlet Temperature Sensor -G191-
- Removing and installing, refer to CENTER VENT TEMPERATURE SENSOR -G191- .