CLIMATRONIC A/C System With Automatic Control Overview
WARNING: This page does not describe the selected car, but rather 9 other vehicles, including the 2009 Volkswagen Rabbit, 2009 Volkswagen GTI, 2008 Volkswagen Rabbit, 2008 Volkswagen R32, and 2008 Volkswagen GTI. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
Disconnect the battery before removing the components marked with **. Refer to [For transmission(s) 0A4, 02E, 09G, 02Q] Removal and Installation .
A data plate indicates the refrigerant used and capacity.
- Dash Panel **
- Removing and installing, refer to Removal and Installation .
- Sunlight Photo Sensor -G107- or Sunlight Photo Sensor 2 -G134-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Tasks: Controls temperature door and fresh air blow depending on light intensity.
- Emergency running in the event of failure: the Climatronic control module -J255- utilizes a fixed value.
- Removing and installing, refer to SUNLIGHT PHOTO SENSORS -G107- / -G134- .
- Indirect Ventilation
- Removing and installing, refer to CLIMATRONIC INDIRECT VENTILATION .
- Center Vents
- Removing and installing, refer to CENTER VENT .
- Right Side Vent
- Air Outlet
- Removing and installing, refer to RIGHT OR LEFT VENT .
- Right Vent Temperature Sensor -G151-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to LEFT AND RIGHT VENT TEMPERATURE SENSORS -G151- / -G150- .
- Climatronic Control Module -J255-
- The Climatronic Control Module and the Front A/C display control head -E87- are one component that cannot be disassembled.
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to CLIMATRONIC A/C CONTROLS .
- Replacing, initiate Basic Setting function with Vehicle Diagnosis, Testing and Information System BVAS 5051. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Vehicles Through 04.07 Air Flow Door Motor -V71- ; From 05.07 Fresh Air/Recirculating Air/Back Pressure Door Motor Position Sensor -V425-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to AIRFLOW DOOR MOTOR -V71-, THROUGH 04.07 on vehicles through 04.0.
- Removing and installing, refer to FRESH AIR/RECIRCULATING AIR/BACK PRESSURE DOOR MOTOR -V425-, FROM 05.07 on vehicles from 05.07.
- Replacing, initiate Basic Setting function with the Vehicle Diagnosis, Testing and Information System VAS 5051B. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Vehicles Through 04.07 Recirculation Door Motor -V113-, From 05.07 the Recirculation Door Motor -V113- is Discontinued.
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to RECIRCULATION DOOR MOTOR -V113- .
- Replacing, initiate Basic Setting function with Vehicle Diagnosis, Testing and Information System VAS 5051B. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Fresh Air Intake Duct Temperature Sensor -G89-
- Only installed on vehicles through 12/05.
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Task: Temperature sensor controls temperature door and fresh air blower depending on temperature.
- To disassemble, remove the instrument panel. Refer to Removal and Installation .
- Right Footwell Vent
- Removing and installing, refer to RIGHT FOOTWELL VENT .
- Fresh Air Blower -V2- with Fresh Air Blower Control Module -J126-
- On vehicles from 11.05, Fresh Air Blower Control Module can be replaced separately.
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Fresh Air Blower, removing and installing, refer to FRESH AIR BLOWER -V2- .
- Fresh Air Blower Control Module, removing and installing, refer to FRESH AIR BLOWER CONTROL MODULE -J126- .
- Connector
- Heating Unit Partition
- Removing, refer to HEATING UNIT PARTITION .
- Cap
- Only in vehicles without air guide to vent installed in center console at rear.
- Dust and Pollen Filter
- With activated charcoal filter.
- Removing and installing, refer to DUST AND POLLEN FILTER .
- Center Console Air Duct Connection (Optional)
- The center console must be removed to remove it. Refer to Removal and Installation .
- Rear Channel For Right Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Rear Channel For Left Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Evaporator Temperature Sensor -G308- or Evaporator Vent Temperature Sensor -G263-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.NOTE:
One or both of the component designations will appear, depending on software. The tasks are the same.
- Removing and installing, refer to EVAPORATOR TEMPERATURE SENSOR -G308- OR EVAPORATOR VENT TEMPERATURE SENSOR -G263- .
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Right Temperature Door Motor -V159-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to RIGHT TEMPERATURE DOOR MOTOR -V159- .
- Replacing, initiate Basic Setting using the Vehicle Diagnosis, Testing and Information System VAS 5051B. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Auxiliary Heater Heating Element -Z35-
- Only installed on vehicles with Diesel engine.
- Heater Core
- Removing and installing, refer to HEATER CORE .
- Central Air Door Motor -V70-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to CENTRAL AIR DOOR MOTOR -V70- .
- Replacing, initiate Basic Setting using the Vehicle Diagnosis, Testing and Information System VAS 5051. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Left Footwell Vent
- Removing and installing, refer to LEFT FOOTWELL VENT .
- Left Temperature Door Motor -V158-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051B.
- Removing and installing, refer to LEFT TEMPERATURE DOOR MOTOR -V158- .
- Replacing, initiate Basic Setting using the Vehicle Diagnosis, Testing and Information System VAS 5051. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Left Footwell Vent Temperature Sensor -G261-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051.
- Removing, refer to LEFT FOOTWELL VENT TEMPERATURE SENSOR -G261- .
- Defroster Door Motor -V107-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051.
- Removing and installing, refer to DEFROSTER DOOR MOTOR V107 .
- Replacing, initiate Basic Setting using the Vehicle Diagnosis, Testing and Information System VAS 5051. Refer to CLIMATRONIC, CHECKING AND ADJUSTING COMPONENTS .
- Heating and A/C unit
- Removing and installing, refer to HEATING AND A/C UNIT .
- Disassembling and assembling CLIMATRONIC HEATING AND A/C UNIT .
- Right Footwell Vent Temperature Sensor -G262-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051.
- Removing, refer to RIGHT FOOTWELL VENT TEMPERATURE SENSOR -G262- .
- Left Side Vent
- Left Vent Temperature Sensor -G150-
- Checking, refer to Vehicle Diagnosis, Testing and Information System VAS 5051.
- Removing and installing, refer to LEFT AND RIGHT VENT TEMPERATURE SENSORS -G151- / -G150- .