Parts of the ignition, removing and installing (Vehicles with engine code AWP, AWW)

WARNING: This page does not describe the selected car, but rather 15 other vehicles, including the 2006 Volkswagen GTI, 2005 Volkswagen Jetta, 2005 Volkswagen GTI, 2004 Volkswagen Jetta, and 2004 Volkswagen GTI. However, it is still accessible from the selected car via links, so may be relevant.

The following list pertains to Fig 1.

Connector
- Black, 4-pin
Ignition coil with power output stage (Ignition Coil 1 with Power Output Stage -N70-, Ignition Coil 2 with Power Output Stage -N127-, Ignition Coil 3 with Power Output Stage - N291-, Ignition Coil 4 with Power Output Stage -N292-)
- Checking, see IGNITION COILS WITH POWER OUTPUT STAGES, CHECKING
Snap ring
- for ignition coil with power output stage (Ignition Coil 1 with Power Output Stage -N70-, Ignition Coil 2 with Power Output Stage -N127-, Ignition Coil 3 with Power Output Stage -N291-, Ignition Coil 4 with Power Output Stage -N292-)
Spark plug, 30 Nm
- remove and install with 3122 B
- Type and spark plug gap, see TEST DATA, SPARK PLUGS
Connector
- black, 3-pin
- Terminals of sensor and connector are gold-plated
10 Nm
Camshaft Position (CMP) Sensor - G40-*
- Checking, see CHECK CAMSHAFT POSITION (CMP) SENSOR
25 Nm
Washer
- Conical
Face plate
- For Camshaft Position (CMP) Sensor 2 -G163-
- note position when installing
20 Nm
- Tightening torque affects function of Knock Sensor (KS)
Knock Sensor (KS) 1 -G61-*
- Terminals of sensor and connector are gold-plated
- Component location: Cylinder block, intake side
- Checking, see CHECK KNOCK SENSORS
Knock Sensor (KS) 2 -G66-*
- Terminals of sensor and connector are gold-plated
- Component location: Cylinder block, intake side
- Checking, see CHECK KNOCK SENSORS
Connector
- 2-pin
- Terminals are gold-plated
- Black for Knock Sensor (KS) 1 -G61-
- Black for Knock Sensor (KS) 2 -G66-
- Mark connector before removing
Ground (GND) wire
- Do not loosen or tighten unless ignition is switched off.
10 Nm
- Do not loosen or tighten unless ignition is switched off.

Fig 1: Ignition System Components With Torque Specifications (Vehicles With Engine Code AWP, AWW)

Courtesy of VOLKSWAGEN OF AMERICA, INC.