LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Volkswagen >> 2003 >> EuroVan Base >> Repair and Diagnosis >> Engine Mechanical >> Accessory Drive Belts >> Specifications & Drive Belt Routing - AXK Engine Code >> Cooling System Specifications >> Cooling System Precautions
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Cooling System Precautions

CAUTION: Only use coolant additive G12 (according to TL VW 774 D).It is a red color. Do NOT mix G12 with any other coolant additive!

If the fluid in expansion tank is brown, G12 has been mixed with other coolant. In this is the case, coolant must be replaced. "G12" and coolant additives marked "In accordance with TL VW 774 D" prevent frost and corrosion damage, scaling and also raise the boiling point of the coolant. Therefore, cooling system must be filled year round with frost and corrosion protection additives.

A higher boiling point improves engine reliability under heavy load particularly in countries with tropical climates. Frost protection additives protect against frost to about -25 C (about -35 C in arctic climates). The coolant concentration must not be reduced by adding water even in warmer seasons and in warmer countries. The anti-freeze ratio must be at least 40%.

If for climatic reasons greater frost protection is required, the amount of G12 can be increased, but only up to 60% (frost protection to about -40 C), otherwise frost protection and cooling effectiveness will be reduced.

CAUTION: Amount of anti-freeze must not exceed 60%; freeze protection and cooling effect will decrease if anti-freeze quantity is too high. See COOLANT MIXTURE RECOMMENDATIONS  .
NOTE: If radiator, heat exchanger, cylinder head or cylinder head gasket has been replaced, do not reuse old coolant.

COOLANT MIXTURE RECOMMENDATIONS

Application Specification
Freeze Point
Down To -13F° (- 25°C) 40% Coolant
Down To -31°F (- 35°C) 50% Coolant