LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Volkswagen >> 2000 >> Passat GLS 4Motion, 4D Sedan >> Repair and Diagnosis >> Maintenance >> Procedures >> Maintenance Procedures >> 01 - Maintenance >> Description of work >> Headlight adjustment, check >> Notes
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Headlight adjustment, check: Notes

Headlight adjustment: Checking on headlights with gas discharge lamps → Headlight with gas discharge lamps .

Special tools, testers and auxiliary items required 

The following test- and adjustment instructions are applicable to all countries. But national legislation and regulations of the respective country is to be adhered to.

Test- and adjustment requirements:

Load: Vehicle must be loaded with one person on the drivers seat, weighing 75 kg, otherwise vehicle must be empty (curb weight).

The curb weight is the weight of the vehicle ready to be operated with filled fuel tank (at least 90% filled), including the weight of all equipment usually carried in the car such as spare wheel, tools, car jack, fire extinguisher, etc.

If the fuel tank is not at least 90% full, adjust the weight as follows:

Tank filling table

Fuel level according to fuel gauge Additional weight in luggage compartment
1/4 45
1/2 30
3/4 15
full 0

Example:

If the fuel tank is half full, place a weight of 30 kg in the luggage compartment.

NOTE:
  • For additional weight use containers filled with water. A container filled with 5 liters of water weighs approx. 5kg.

Move vehicle back and forth for 1 meter (3 to 4 feet) or bounce front and rear of vehicle several times up and down to settle suspension.

Inclination figures:

The inclination figure in "%" is embossed on the top of the headlight housing. The headlights must be set to this figure. Percentage information is based on a projection distance of 10 meters. For example: inclination of 1.2 % converts to approx. 12 cm.