Technical Service Bulletins
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Radio, Anti-Theft Radio Security Code Retrieval Procedures (GROUP 91, NO. 05-02)
- New Replacement Doors - Seat Belt Buckle Support (GROUP 69, NO. 97-05)
- Hood Lock Cable Removing/Installing (GROUP 55, NO. 96-02)
- Lock Carrier With Attachments Removing/Installing (GROUP 50, NO. 96-03)
- Front/Rear Door Seals Friction Noise (GROUP 58, NO. 95-08)
- Hood Lock Fastener Torque Revision (GROUP 55, NO. 95-01)
- Removing And Repairing Sunroof Cable Assemblies (GROUP 60, NO. 95-01)
- Sunroof Makes Popping Noise Or Jams While Opening (GROUP 60, NO. 94-03)
- Wind Noise From Outside Rear View Mirrors (GROUP 66, NO. 94-02)
- Alarm System Control Module, Unnecessary Replacement (GROUP 90, NO. 94-02)
- Anti-Theft Alarm System - Troubleshooting (GROUP 90, NO. 94-03)
- Central Locking System - Troubleshooting (GROUP 57, NO. 94-02)
- Central Locking System Pneumatic Operation - Diag. (GROUP 57, NO. 94-03)
- Hood - Unable To Open Hood With Release Handle (GROUP 55, NO. 93-03)
- Door Panel Vapor Barrier Removal Procedure (GROUP 70, NO. 93-02)
- Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Transmission Code Identification (TT 37-06-12)
- Automatic Transmission, Repairing (GROUP 37, NO. 05-01)
- Transmission, Pan Gasket Appears To Be Leaking (GROUP 37, NO. 01-01)
- Torque Converter With Needle Bearing, Installing On Transmission With Bushing On Turbine Shaft (GROUP 32, NO. 00-01)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Ag4 Automatic Transmissions, Fault 00652 Repair (TT 37-98-25)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Ag4 - Erratic Shifting - No DTC'S Stored (GROUP 01, NO. 97-17)
- DIGIMAT Transmission Control Module Replacing - 49S (GROUP 00, NO. 97-01)
- Ag4 Automatic Transmission - Fault 00293 (TT 37-97-13)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Shift Points/Stall Speed Checking - 096 Transmission (GROUP 37, NO. 96-04)
- Valve Body Conductor Strip Replacement - Trans. 096 (GROUP 37, NO. 96-03)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-01)
- Transmission 096/098 Phase 0 & Phase I Variations (GROUP 37, NO. 94-01)
- A/T Valve Body Replacement: New Valve Body & Oil Pan (GROUP 38, NO. 93-05)
- Access For Checking A/T Fluid Level: New Dipstick (GROUP 38, NO. 93-03)
- Checking Resistance Of ATF Temperature Sensor (GROUP 01, NO. 93-02)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Automatic TANSMISSION 096 - Will Not Move In "D" (GROUP 38, NO. 93-01)
- Auto. Trans. 096 - Main Pressure Checking (GROUP 37, NO. 93-06)
- Automatic Transmission 096 - Technical Data (GROUP 37, NO. 93-07)
- Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- DIGIMAT Control Module Identification - 50 State (GROUP 00, NO. 97-06)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-06)
- J 1930 Nomenclature Revisions (GROUP 00, NO. 96-01)
- 2.0L Aba - Mil On - O2 Sensor DTC Stored In Memory (GROUP 01, NO. 96-05)
- Heated Oxygen Sensor Troubleshooting (GROUP 24, NO. 95-04)
- 2.0L Camshaft Position Sensor (G40) Checking (GROUP 28, NO. 95-03)
- VAG 1551 Scan Tool Diagnostics (GROUP 01, NO. 95-01)
- Battery Charging Precautions (GROUP 27, NO. 95-02)
- 2.0L Knock Sensor Troubleshooting DTC 00524 (2142) (GROUP 01, NO. 94-03)
- 2.8L Knock Sensor DTC 00524 (2142)/00540 (2144) (GROUP 01, NO. 94-04)
- Heated Oxygen Sensor Replacement (GROUP 24, NO. 94-05)
- Engine Control Module Wiring Harness Routing (GROUP 97, NO. 94-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Pulsating/Clicking Noise From Engine/Vehicle Front (GROUP 24, NO. 94-04)
- Engine Control Module, Replacing (GROUP 24, NO. 94-03)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- DTC 00533 2231 - Noise Damper For IAC Valve (GROUP 24, NO. 93-05)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Throttle Position Sensor Replacement: New Parts (GROUP 24, NO. 93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- 1.8L - Camshaft Position Sensor Checking (GROUP 28, NO. 93-02)
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Sensor Checking (TT 97-06-64)
- Throttle Position (TP) Sensor -G69-, Installing New Style Switch (GROUP 24, NO. 03-02)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- DIGIMAT Control Module Identification - 50 State (GROUP 00, NO. 97-06)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-06)
- 2.0L Aba - Mil On - O2 Sensor DTC Stored In Memory (GROUP 01, NO. 96-05)
- 2.0L Camshaft Position Sensor (G40) Checking (GROUP 28, NO. 95-03)
- VAG 1551 Scan Tool Diagnostics (GROUP 01, NO. 95-01)
- Battery Charging Precautions (GROUP 27, NO. 95-02)
- 2.0L Knock Sensor Troubleshooting DTC 00524 (2142) (GROUP 01, NO. 94-03)
- 2.8L Knock Sensor DTC 00524 (2142)/00540 (2144) (GROUP 01, NO. 94-04)
- Heated Oxygen Sensor Replacement (GROUP 24, NO. 94-05)
- Engine Control Module Wiring Harness Routing (GROUP 97, NO. 94-01)
- Engine Control Module, Replacing (GROUP 24, NO. 94-03)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- DTC 00533 2231 - Noise Damper For IAC Valve (GROUP 24, NO. 93-05)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Throttle Position Sensor Replacement: New Parts (GROUP 24, NO. 93-03)
- 1.8L - Camshaft Position Sensor Checking (GROUP 28, NO. 93-02)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Headlights
- Horns
- HVAC Control Systems
- Identification
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Interior, Cleaning Tips For Fabrics, Vinyls And Plastics (GROUP 70, NO. 99-01)
- Interior, Cleaning Tips For Leather Upholstery (GROUP 70, NO. 99-02)
- Exhaust Heat Shield, Replacement Guidelines (GROUP 26, NO. 08-02)
- Body Side Moldings, Painting (GROUP 57, NO. 00-03)
- SUBFRAME Mounting/Repairing (GROUP 40, NO. 96-01)
- Lock Carrier With Attachments Removing/Installing (GROUP 50, NO. 96-03)
- Sun Visor Inboard Clip Cracked Around Screw (GROUP 68, NO. 95-05)
- Front/Rear Door Seals Friction Noise (GROUP 58, NO. 95-08)
- Door Glass Seal - Wind Noise At A-Pillar (GROUP 57, NO. 95-07)
- Hood Lock Fastener Torque Revision (GROUP 55, NO. 95-01)
- Deteriorated Front/Rear VW Emblem: New Emblems (GROUP 66, NO. 93-03)
- Horn Pad Assembly Removal: New Procedure (GROUP 48, NO. 93-05)
- Radiator Grille Removing (GROUP 66, NO. 93-02)
- Door Panel Vapor Barrier Removal Procedure (GROUP 70, NO. 93-02)
- Wind Noise From Sunroof - Sunroof Seal Adjusting (GROUP 60, NO. 93-01)
- Roof Trim Assembly/Headliner - Removing (GROUP 70, NO. 93-01)
- Interior/Illumination Lights
- Locking Hubs
- Lubrication System
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- 2.0L - Oil Accumulation In Intake Air Supply STSTEM (GROUP 24, NO. 95-03)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-01)
- 2.0L Fuel Pressure Regulator Checking (GROUP 24, NO. 94-09)
- 1.9L Diesel - Metal Cylinder Head Gasket (GROUP 15, NO. 94-01)
- Engine Oil And Oil Additives (GROUP 17, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Lubrication System - Specification Change (GROUP 17, NO. 93-01)
- Manual Steering
- Manual Trans
- Mechanical
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- All Model Year Engines With Adjustable Cam Timing - Knocking Noise From Chain TENSIONER/Adjuster (TT 15-06-106)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Poor Performance/Exhaust Smoke Visible (GROUP 13, NO. 97-07)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Main Bearing Cap Tightening Torque (GROUP 13, NO. 96-01)
- Turbo Diesel Engine Hard Starting - CANADA Only (GROUP 23, NO. 96-02)
- 2.0L - Oil Accumulation In Intake Air Supply STSTEM (GROUP 24, NO. 95-03)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- 2.0L Fuel Pressure Regulator Checking (GROUP 24, NO. 94-09)
- 1.9L Diesel - CYLIDER Head Swirl Chambers Replacing (GROUP 15, NO. 94-02)
- 1.9L Diesel - Metal Cylinder Head Gasket (GROUP 15, NO. 94-01)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Camshaft Timing Specification Change (GROUP 15, NO. 93-01)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Mechanical - Hydraulic
- Mirrors
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Schedule
- Seats
- Interior, Cleaning Tips For Fabrics, Vinyls And Plastics (GROUP 70, NO. 99-01)
- Interior, Cleaning Tips For Leather Upholstery (GROUP 70, NO. 99-02)
- Sunroof Won't Close With Convenience Close Feature (GROUP 60, NO. 97-02)
- New Replacement Doors - Seat Belt Buckle Support (GROUP 69, NO. 97-05)
- Installing Child Safety Seat On Front Passenger Seat (GROUP 69, NO. 95-04)
- Rear Child Restraint Anchorages (GROUP 69, NO. 95-05)
- Sunroof Noise And Vibration While Open (GROUP 60, NO. 94-05)
- Sunroof Makes Popping Noise Or Jams While Opening (GROUP 60, NO. 94-03)
- Front Electric Window Regulator Servicing (GROUP 57, NO. 94-05)
- Central Locking System - Troubleshooting (GROUP 57, NO. 94-02)
- Central Locking System Pneumatic Operation - Diag. (GROUP 57, NO. 94-03)
- Hood - Unable To Open Hood With Release Handle (GROUP 55, NO. 93-03)
- Starter
- Steering Column
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Sun Roof/T-Top/Convertible Top
- Suspension Control Systems
- System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- Throttle Position (TP) Sensor -G69-, Installing New Style Switch (GROUP 24, NO. 03-02)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Spark Plug Connector - Using Proper Removal Tool (GROUP 28, NO. 00-01)
- Silicone Contamination (TT 24-00-35)
- Poor Performance/Exhaust Smoke Visible (GROUP 13, NO. 97-07)
- DIGIMAT Control Module Identification - 50 State (GROUP 00, NO. 97-06)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-06)
- J 1930 Nomenclature Revisions (GROUP 00, NO. 96-01)
- 2.0L Aba - Mil On - O2 Sensor DTC Stored In Memory (GROUP 01, NO. 96-05)
- Ignition Coil Wire Checking/Replacing (GROUP 28, NO. 96-01)
- Turbo Diesel Engine Hard Starting - CANADA Only (GROUP 23, NO. 96-02)
- Heated Oxygen Sensor Troubleshooting (GROUP 24, NO. 95-04)
- 2.0L Camshaft Position Sensor (G40) Checking (GROUP 28, NO. 95-03)
- 2.0L (Aba) - Power Output Stage Replacement (GROUP 28, NO. 95-02)
- VAG 1551 Scan Tool Diagnostics (GROUP 01, NO. 95-01)
- Battery Charging Precautions (GROUP 27, NO. 95-02)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- 2.0L Fuel Pressure Regulator Checking (GROUP 24, NO. 94-09)
- 2.0L Knock Sensor Troubleshooting DTC 00524 (2142) (GROUP 01, NO. 94-03)
- 2.8L Knock Sensor DTC 00524 (2142)/00540 (2144) (GROUP 01, NO. 94-04)
- 1.9L Diesel - Metal Cylinder Head Gasket (GROUP 15, NO. 94-01)
- Heated Oxygen Sensor Replacement (GROUP 24, NO. 94-05)
- Spark Plug Application - Information (GROUP 28, NO. 94-01)
- Engine Control Module Wiring Harness Routing (GROUP 97, NO. 94-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Pulsating/Clicking Noise From Engine/Vehicle Front (GROUP 24, NO. 94-04)
- Engine Control Module, Replacing (GROUP 24, NO. 94-03)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- DTC 00533 2231 - Noise Damper For IAC Valve (GROUP 24, NO. 93-05)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Throttle Position Sensor Replacement: New Parts (GROUP 24, NO. 93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- 1.8L - Camshaft Position Sensor Checking (GROUP 28, NO. 93-02)
- 1.8L - Ignition Coil Checking - Revised Procedure (GROUP 28, NO. 93-01)
- Towing
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- Window Motors & Regulators
- Sunroof Won't Close With Convenience Close Feature (GROUP 60, NO. 97-02)
- Door Glass Seal - Wind Noise At A-Pillar (GROUP 57, NO. 95-07)
- Removing And Repairing Sunroof Cable Assemblies (GROUP 60, NO. 95-01)
- Sunroof Noise And Vibration While Open (GROUP 60, NO. 94-05)
- Sunroof Makes Popping Noise Or Jams While Opening (GROUP 60, NO. 94-03)
- Front Electric Window Regulator Servicing (GROUP 57, NO. 94-05)
- Central Locking System - Troubleshooting (GROUP 57, NO. 94-02)
- Central Locking System Pneumatic Operation - Diag. (GROUP 57, NO. 94-03)
- Hood - Unable To Open Hood With Release Handle (GROUP 55, NO. 93-03)
- Window Glass - Installing Instructions (GROUP 64, NO. 93-01)
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)