Technical Service Bulletins: Other Variant
WARNING: This page is about the EuroVan CL, 2.5 C, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- R-134A Refrigerant Systems - Replacement & Capacity (GROUP 87, NO. 94-01)
- Rear A/C Does Not Cool - Sticking Shut-Off Valve (GROUP 87, NO. 93-07)
- A/C Compressor Leaks Refrigerant R-134A (GROUP 87, NO. 93-04)
- ACR4-R134A Refrigerant Recovery/Recycling/Recharging (V 92-03)
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Lock Brakes
- Anti-Theft Systems
- Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Automatic Transmission, Repairing (GROUP 37, NO. 05-01)
- Torque Converter With Needle Bearing, Installing On Transmission With Bushing On Turbine Shaft (GROUP 32, NO. 00-01)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- 096/098 Automatic TRANSMISSSION Troubleshooting (GROUP 37, NO. 94-02)
- Transmission 096/098 Phase 0 & Phase I Variations (GROUP 37, NO. 94-01)
- Checking Resistance Of ATF Temperature Sensor (GROUP 01, NO. 93-02)
- Automatic Transmission 098 - Technical Data (GROUP 37, NO. 93-12)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Automatic Transmission Ag4 - Will Not Move In "D" (GROUP 38, NO. 93-02)
- Axle Shaft Bolts - Torque Revised (GROUP 40, NO. 93-03)
- Auto. Trans. 098 - Shift Point Specifications (GROUP 37, NO. 93-05)
- Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- J 1930 Nomenclature Revisions (GROUP 00, NO. 96-01)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Idle Speed & Co Content, Checking/Adjusting (GROUP 24, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Speed And Co Adjusting (GROUP 24, NO. 92-05)
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Clutch
- Communication Devices
- Cooling System (Mechanical)
- 19-17-01 - Identifying And Mixing VOLKSWAGEN Engine Coolants (U.S. Only) (GROUP 19, NO. 17-01)
- Coolant (Antifreeze), Mixing Precautions (GROUP 19, NO. 02-01)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Cooling System Anti-Freeze Protection Level Checking (96-06)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Coolant System Capacity - Service Manual Revision (GROUP 19, NO. 94-01)
- Coolant Pump Leakage Troubleshooting (GROUP 19, NO. 93-01)
- Cruise Control Systems
- Differentials & Drive Axles
- Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Exterior Lights
- Frames, Subframes & Crossmembers
- Front Suspension
- Fuel System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing
- Horns
- HVAC Control Systems
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Air Conditioner Odor (TT 87-97-20)
- R-134A Refrigerant Systems - Replacement & Capacity (GROUP 87, NO. 94-01)
- Rear A/C Does Not Cool - Sticking Shut-Off Valve (GROUP 87, NO. 93-07)
- Reducing Interior Noise: New Insulated Air Duct (GROUP 70, NO. 93-03)
- A/C Compressor Leaks Refrigerant R-134A (GROUP 87, NO. 93-04)
- MASTERCOOL 93000 A/C Spring Lock Coupling Kit (V 92-10)
- ACR4-R134A Refrigerant Recovery/Recycling/Recharging (V 92-03)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Lubrication System
- 2.0L FSI Turbo (BPY) And All 2.5L Engines, Oil Filter Cartridge Replacing (TT 17-06-100)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Engine Oil And Oil Additives (GROUP 17, NO. 94-02)
- Manual Steering
- Manual Trans
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Universal Transmission Support 3282 (GROUP 00, NO. 93-04)
- 02B Manual Transmission Changes In Clutch Housing (GROUP 34, NO. 92-11)
- 02B Manual Transmission Mount Revised (GROUP 34, NO. 92-10)
- 5-Speed 02B Transmission - Changes/Modifications (GROUP 34, NO. 92-08)
- Trans. 02B - Installing Right Side Drive Flange (GROUP 34, NO. 92-09)
- Mechanical
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- 2.0L FSI Turbo (BPY) And All 2.5L Engines, Oil Filter Cartridge Replacing (TT 17-06-100)
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- All Model Year Engines With Adjustable Cam Timing - Knocking Noise From Chain TENSIONER/Adjuster (TT 15-06-106)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Camshaft Drive Chain Modified (GROUP 13, NO. 98-01)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Sparking From Tooth Belt Cover: New Belt Cover (GROUP 27, NO. 93-13)
- Vibration Damper - Removing/Installing (GROUP 13, NO. 93-06)
- Hydraulic Lifters Checking (Revised Procedure) (GROUP 15, NO. 93-03)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Mechanical - Hydraulic
- New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Park Brake Lever Spring Sleeve - Installed Position (GROUP 46, NO. 93-01)
- Added Pre-Delivery Repair Instructions (GROUP 00, NO. 92-08)
- Overdrive Unit
- Paint & Coatings
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column Switches
- Steering Control Systems
- Steering Gear
- Suspension Control Systems
- System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Sealants, Liquid Gaskets And Lubricants Containing Silicone (GROUP 00, NO. 08-04)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Spark Plug Connector - Using Proper Removal Tool (GROUP 28, NO. 00-01)
- Silicone Contamination (TT 24-00-35)
- J 1930 Nomenclature Revisions (GROUP 00, NO. 96-01)
- Ignition System Timing Advance Checking/Adjusting (GROUP 28, NO. 95-01)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Idle Speed & Co Content, Checking/Adjusting (GROUP 24, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Speed And Co Adjusting (GROUP 24, NO. 92-05)
- Revised Spark Plug Application (GROUP 28, NO. 92-03)
- Transmission Control Systems
- Vacuum Pumps/Lines/Tanks/Water Trap
- Warning Systems
- Wheels & Tire System
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Alloy Wheels Cleaning (GROUP 44, NO. 99-03)
- Vehicle Pulls/Drifts To One Side - Rotate Tires (GROUP 44, NO. 94-01)
- Wheels/Tires, Eliminating Vibrations - Information (GROUP 44, NO. 94-03)
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Wiper/Washer Systems
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Windshield Wiper Blades Skipping (GROUP 92, NO. 95-02)
- Infinitely Variable Intermittent Wiper Relay (GROUP 92, NO. 93-01)
- Windshield Wiper: Variable Intermittent Operation (GROUP 92, NO. 92-02)
- Added Pre-Delivery Repair Instructions (GROUP 00, NO. 92-08)
- Transportation Wiper Blades Installed In Production (GROUP 92, NO. 92-01)
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)