Technical Service Bulletins: Other Variant
WARNING: This page is about the Vanagon Base, Automatic, which is a different variant/trim than selected.
- A/C Compressor
- Accessories & Equipment
- Accessories Control Systems
- Accessory Drive Belts
- Air Bag, SRS
- Anti-Theft Systems
- Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Automatic Transmission, Repairing (GROUP 37, NO. 05-01)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Final Drive Housing Cover Leakage (GROUP 39, NO. 91-03)
- Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Blowers, Superchargers & Turbochargers
- Body Electrical
- Body Interior
- Brakes Control Systems
- Charging Systems
- Communication Devices
- Cooling System (Mechanical)
- 19-17-01 - Identifying And Mixing VOLKSWAGEN Engine Coolants (U.S. Only) (GROUP 19, NO. 17-01)
- Coolant (Antifreeze), Mixing Precautions (GROUP 19, NO. 02-01)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Coolant Pump Leakage Troubleshooting (GROUP 19, NO. 93-01)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Cruise Control Systems
- Differentials & Drive Axles
- Electronic Steering
- Electronic Suspension
- Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Special Tool To Remove/Install Fuel Sending Unit (GROUP 20, NO. 90-03)
- Entertainment Systems
- Exhaust
- Exterior Body Panels
- Front Suspension
- Fuel System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Special Tool To Remove/Install Fuel Sending Unit (GROUP 20, NO. 90-03)
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- Speedometer Replacement - Compliance With Regulation (GROUP 90, NO. 97-01)
- Speedometer Replacement - CANADIAN Gov. Regulations (GROUP 90, NO. 96-02)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Speedometer Replacing - Disclosure Requirements (GROUP 90, NO. 92-02)
- Special Tool To Remove/Install Fuel Sending Unit (GROUP 20, NO. 90-03)
- General Servicing
- HVAC Control Systems
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Air Conditioner Odor (TT 87-97-20)
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- A/C Evaporator & Housing/Cabinet, Removing (GROUP 87, NO. 91-07)
- A/C Compressor Valve Plate, Head & Gasket Replacing (GROUP 87, NO. 91-06)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
- Ignition Switch/Steering Lock
- Ignition System
- Interior/Exterior Trim
- Lubrication System
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Engine Oil And Oil Additives (GROUP 17, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Manual Steering
- Manual Trans
- Mechanical
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- All Model Year Engines With Adjustable Cam Timing - Knocking Noise From Chain TENSIONER/Adjuster (TT 15-06-106)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- Mechanical - Hydraulic
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Adapter VAG 1310/6 For Brake Press. Regulator (GROUP 47, NO. 92-02)
- Brake Fluid Super Dot 4 - Description/Application (GROUP 47, NO. 92-01)
- Rear Wheel Brake Cylinder Replacement Criteria (GROUP 46, NO. 91-01)
- Mirrors
- Paint & Coatings
- 00-17-06 - Removing Paint Contaminants From Exterior Paint (GROUP 00, NO. 17-06)
- Technical Bulletin Materials / 3M Distribution Centers (TT 00-09-03)
- RESTORIATION Of Chalked/Oxidized/Contaminated Paint (GROUP 50, NO. 91-06)
- Clear Coat Repair - Soak In Isopropyl Alcohol First (GROUP 50, NO. 91-08)
- Water Borne UNICOLOR Paints (GROUP 50, NO. 91-07)
- Engine Compartment Protection/Acrylic Coating (GROUP 50, NO. 92-02)
- Passive Restraints
- Rear Suspension
- Restraints Control Systems
- Seats
- Starter
- Steering Column
- Steering Control Systems
- Steering Gear
- Steering Linkage
- Suspension Control Systems
- System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Special Tool To Remove/Install Fuel Sending Unit (GROUP 20, NO. 90-03)
- Transmission Control Systems
- Wheel Alignment
- Wheels & Tire System
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Alloy Wheels Cleaning (GROUP 44, NO. 99-03)
- Vehicle Pulls/Drifts To One Side - Rotate Tires (GROUP 44, NO. 94-01)
- Wheels/Tires, Eliminating Vibrations - Information (GROUP 44, NO. 94-03)
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Recommended Tire Sizes/Inflation Pressures (GROUP 44, NO. 91-04)
- Tire Application Chart (GROUP 44, NO. 91-03)
- Aerosol Tire Inflator/Sealer - Flammability Hazard (GROUP 44, NO. 91-02)
- Tire Rotation/Wear Diagnosis/Information (GROUP 44, NO. 90-06)
- Window Motors & Regulators
- Wiper/Washer Systems
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)