Technical Service Bulletins

A/C Compressor
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- A/C Compressor Clutch, Removing & Installing (GROUP 87, NO. 91-04)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
Accessories & Equipment
- New Vas 6161 Battery Tester (TT 27-10-02)
Accessories Control Systems
- Sensor Checking (TT 97-06-64)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- Refrigerator Air Supply Modification (DOMETIC 182) (GROUP 76, NO. 89-01)
Accessory Drive Belts
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
Anti-Theft Systems
- Re-Keying Locks To Maintain One-Key Operation (GROUP 57, NO. 89-01)
- Lost/Broken Keys - Key Code Locations On Door Handle (GROUP 57, NO. 87-03)
- Push Button Operation Difficult - Rear Lid Latch (GROUP 55, NO. 87-01)
- Correct Installation Of Outside Sliding Door Handle (GROUP 58, NO. 85-01)
- Sliding Door - Removing/Installing/Adjusting (GROUP 58, NO. 84-01)
Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Speedometer Noisy - Revised Speedometer & Cable (GROUP 90, NO. 91-02)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
- 010 Trans Slips Around Turns,DECEL - New Filter/GASK (GROUP 37, NO. 87-01)
- Gasoline Additive Removes Carbon Deposits (GROUP 15, NO. 85-02)
- Automatic Transmission - Checking ATF Level (GROUP 37, NO. 85-01)
- A/T 090 - Shift Point/Stall Speed/Main Pressure Spec (GROUP 37, NO. 84-03)
- A/T 090 With Code Letters NH - Modifications (GROUP 38, NO. 84-03)
Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- Water Cooled Engine Stalls/Misses Intermittently (GROUP 97, NO. 87-07)
- Engine Stops Running - Ignition Control Unit (GROUP 28, NO. 87-05)
- Catalytic Converter - Checking/Replacement Procedure (GROUP 26, NO. 85-03)
- Fuel Injection System - Throttle Valve Check/Adjust (GROUP 24, NO. 85-01)
Axle Shafts
- Steering Knuckle Modification, Prevent Interference (GROUP 40, NO. 92-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
Blowers, Superchargers & Turbochargers
- Alternator V-Belt Adjustment (GROUP 13, NO. 92-01)
Body Electrical
- Wiring Harness Repairing (TT 97-01-23)
Body Interior
- Sensor Checking (TT 97-06-64)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Brakes Control Systems
- Sensor Checking (TT 97-06-64)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Charging Systems
- Wiring Harness Repairing (TT 97-01-23)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Alternator V-Belt Adjustment (GROUP 13, NO. 92-01)
- Alt MOUNTNG Bolt Loose/Broken - New Torque Spec (GROUP 27, NO. 87-04)
- Alternator Mounting Bolts Loose (GROUP 27, NO. 84-03)
Clutch
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Clutch Disc Hub/Matching Spline Lubrication Info (GROUP 30, NO. 89-01)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
- Grinds Into 1ST/Reverse - Clutch Disc Binding (GROUP 34, NO. 87-01)
Communication Devices
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Tarpaulin - Service Installation Procedure (CANADA) (GROUP 61, NO. 85-01)
Cooling System (Mechanical)
- 19-17-01 - Identifying And Mixing VOLKSWAGEN Engine Coolants (U.S. Only) (GROUP 19, NO. 17-01)
- Coolant (Antifreeze), Mixing Precautions (GROUP 19, NO. 02-01)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Coolant Pump Leakage Troubleshooting (GROUP 19, NO. 93-01)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- 1.9L/2.1L WATERBOXER - Cylinder Head Reseal (GROUP 15, NO. 15-90-T01)
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- Oil Cooler Seal Leaks In Extreme Cold (GROUP 17, NO. 87-05)
- Oil Leak From Rear - Oil Pump Gasket (GROUP 17, NO. 87-04)
- Coolant Leaking &/Or Noise From Rear Water Pump (GROUP 19, NO. 87-02)
- Coolant Temperature Gauge Light Flashes (GROUP 90, NO. 87-03)
Cruise Control Systems
- Cruise Control Does Not Work - Vacuum Loss (GROUP 27, NO. 87-03)
Differentials & Drive Axles
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
- Gasoline Additive Removes Carbon Deposits (GROUP 15, NO. 85-02)
Driveshaft & Universal Joints
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
Electronic Steering
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
Electronic Suspension
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- Water Cooled Engine Stalls/Misses Intermittently (GROUP 97, NO. 87-07)
- Engine Stops Running - Ignition Control Unit (GROUP 28, NO. 87-05)
- Fuel Injection System - Throttle Valve Check/Adjust (GROUP 24, NO. 85-01)
Entertainment Systems
- Radio Diagnosis Instructions (GROUP 91, NO. 94-02)
- Static In Radio In Am Mode - Radio Suppression (GROUP 91, NO. 87-02)
- Non-Interchangeable Cigarette Lighters (GROUP 90, NO. 86-02)
Exhaust
- Exhaust Restriction Testing Tip (TT 26-09-01)
- Catalytic Converter - Checking/Replacement Procedure (GROUP 26, NO. 85-03)
Exterior Body Panels
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Identifying/Painting/Repairing Plastic Parts (GROUP 50, NO. 85-04)
- Installing Body Parts With Corrosion Protective Seal (GROUP 50, NO. 85-01)
Exterior Lights
- Instrument Indicator Lights Malfunction (GROUP 90, NO. 90-02)
- Interior Light Inoperative - Door Contact Switch (GROUP 96, NO. 87-01)
Frames, Subframes & Crossmembers
- Installing Body Parts With Corrosion Protective Seal (GROUP 50, NO. 85-01)
Front Suspension
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
- Upper Control Arm Bushings, Checking (GROUP 40, NO. 88-01)
- Suspension Components - Wax Coating Cavities (GROUP 40, NO. 87-01)
- Front Suspension - New Lower Control Arm & Strut Bar (GROUP 40, NO. 85-01)
Fuel System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- P.I. 2082 - Accelerator Cable Change (GROUP 20, NO. 90-01)
Fuses & Circuit Breakers
- Wiring Harness Repairing (TT 97-01-23)
Gauges & Instrument Panels
- Speedometer Replacement - Compliance With Regulation (GROUP 90, NO. 97-01)
- Speedometer Replacement - CANADIAN Gov. Regulations (GROUP 90, NO. 96-02)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Speedometer Replacing - Disclosure Requirements (GROUP 90, NO. 92-02)
- Speedometer Noisy - Revised Speedometer & Cable (GROUP 90, NO. 91-02)
- Instrument Indicator Lights Malfunction (GROUP 90, NO. 90-02)
- Coolant Temperature Gauge Light Flashes (GROUP 90, NO. 87-03)
- Instrument Panel - Milky/Spotted (GROUP 70, NO. 87-01)
- Speedometer Calibration (GROUP 90, NO. 86-03)
General Servicing
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
Headlights
- Instrument Indicator Lights Malfunction (GROUP 90, NO. 90-02)
- Interior Light Inoperative - Door Contact Switch (GROUP 96, NO. 87-01)
HVAC Control Systems
- Air Conditioner Odor (TT 87-97-20)
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- A/C Evaporator & Housing/Cabinet, Removing (GROUP 87, NO. 91-07)
- A/C Compressor Valve Plate, Head & Gasket Replacing (GROUP 87, NO. 91-06)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
- A/C Evaporator - Water Leaking - Water From Vents (GROUP 87, NO. 90-01)
- Carpet Wet By Rear Seat: Heat EXCHANGER T-Piece Leak (GROUP 19, NO. 88-02)
- Removing Noise Damper From A/C High Pressure Hose (GROUP 87, NO. 87-04)
- Carpet Wet By Rear Seat - Heat EXCHANGER Bleeder (GROUP 80, NO. 87-01)
- Replacement Of A/C Refrigerant Hose Mounting Clamps (GROUP 87, NO. 85-01)
- A/C Evaporator Blower Motor Reinforcement Plate (GROUP 87, NO. 84-06)
Identification
- Remanufactured Engine Identification (GROUP 10, NO. 87-02)
Ignition Switch/Steering Lock
- Manual Rotation Of Ignition Switch During Lock Cylinder Or Housing Replacement (TT 28-10-01)
- Re-Keying Locks To Maintain One-Key Operation (GROUP 57, NO. 89-01)
Ignition System
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- Ignition Related Engine Miss: New Ignition Connector (GROUP 28, NO. 90-02)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- Hall Sensor Ignition Kit Parts Information (GROUP 28, NO. 89-01)
- Engine Stops Running - Ignition Control Unit (GROUP 28, NO. 87-05)
- Miss,Rough Idle/Part Load - Plug Connector/Dist Cap (GROUP 28, NO. 87-04)
- Ignition Distributor Trigger Wheel Removal (GROUP 28, NO. 87-01)
- Ignition System - Ignition Cable Removal (GROUP 28, NO. 86-08)
- Ignition System - New Ignition Cable Connectors (GROUP 28, NO. 85-01)
Interior/Exterior Trim
- Cleaning Non Painted Plastic Exterior Trim Parts (GROUP 66, NO. 91-02)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Lost/Broken Keys - Key Code Locations On Door Handle (GROUP 57, NO. 87-03)
- Gap Forms In Carpet Seams Between Front Seats (GROUP 70, NO. 87-02)
- Vent Window Sticks To Weatherstrip (GROUP 64, NO. 87-03)
- Identifying/Painting/Repairing Plastic Parts (GROUP 50, NO. 85-04)
- Correct Installation Of Outside Sliding Door Handle (GROUP 58, NO. 85-01)
- Tarpaulin - Service Installation Procedure (CANADA) (GROUP 61, NO. 85-01)
- Installing Body Parts With Corrosion Protective Seal (GROUP 50, NO. 85-01)
Interior/Illumination Lights
- Instrument Indicator Lights Malfunction (GROUP 90, NO. 90-02)
- Interior Light Inoperative - Door Contact Switch (GROUP 96, NO. 87-01)
Locking Hubs
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
Lubrication System
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Engine Oil And Oil Additives (GROUP 17, NO. 94-02)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- 1.9L/2.1L WATERBOXER - Cylinder Head Reseal (GROUP 15, NO. 15-90-T01)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- Oil Cooler Seal Leaks In Extreme Cold (GROUP 17, NO. 87-05)
- Oil Leak From Rear - Oil Pump Gasket (GROUP 17, NO. 87-04)
- Gasoline Additive Removes Carbon Deposits (GROUP 15, NO. 85-02)
Manual Steering
- Power Steering - Instructions For R & I & Repair (GROUP 48, NO. 84-02)
Manual Trans
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Universal Transmission Support 3282 (GROUP 00, NO. 93-04)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Speedometer Noisy - Revised Speedometer & Cable (GROUP 90, NO. 91-02)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Revised Shift Lever Bearing Adjusting (GROUP 34, NO. 89-03)
- Shift Rod Bushing Boot Positioning (GROUP 34, NO. 89-02)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
- 4-SPD 091/1 & 5-SPD 094 - Modified MAINSHAFT CIRCLIP (GROUP 35, NO. 87-01)
- Lubrication Of Gearshift Linkage (GROUP 34, NO. 86-01)
- 091/I Trans. - Gear Ratios & Lubricant Specification (GROUP 34, NO. 85-01)
- 4-Speed Manual Trans. 091/1 - Modifications (GROUP 35, NO. 84-02)
Mechanical
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- 1.9L/2.1L WATERBOXER - Cylinder Head Reseal (GROUP 15, NO. 15-90-T01)
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- Oil Cooler Seal Leaks In Extreme Cold (GROUP 17, NO. 87-05)
- Oil Leak From Rear - Oil Pump Gasket (GROUP 17, NO. 87-04)
- Alt MOUNTNG Bolt Loose/Broken - New Torque Spec (GROUP 27, NO. 87-04)
- Hydraulic Valve Lifter Noise (GROUP 15, NO. 87-02)
- Remanufactured Engine Identification (GROUP 10, NO. 87-02)
- 1.9L - Replacing Crankcase With 2.1L Crankcase (GROUP 13, NO. 87-02)
- Removing Piston Pin Hole Burrs With Reamer 3159 (GROUP 13, NO. 87-01)
- Alternator Mounting Bolts Loose (GROUP 27, NO. 84-03)
- 1.9L Water-Cooled - Revised Cylinder Head Torque (GROUP 15, NO. 84-04)
Mechanical - Hydraulic
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Adapter VAG 1310/6 For Brake Press. Regulator (GROUP 47, NO. 92-02)
- Brake Fluid Super Dot 4 - Description/Application (GROUP 47, NO. 92-01)
- Rear Wheel Brake Cylinder Replacement Criteria (GROUP 46, NO. 91-01)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
- Brake Squeak - Rear - Shoes Rubbing Backplate (GROUP 46, NO. 87-01)
- Gasoline Additive Removes Carbon Deposits (GROUP 15, NO. 85-02)
Mirrors
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
Paint & Coatings
- 00-17-06 - Removing Paint Contaminants From Exterior Paint (GROUP 00, NO. 17-06)
- Technical Bulletin Materials / 3M Distribution Centers (TT 00-09-03)
- RESTORIATION Of Chalked/Oxidized/Contaminated Paint (GROUP 50, NO. 91-06)
- Engine Compartment Protection/Acrylic Coating (GROUP 50, NO. 92-02)
- Acid Rain Spots On Paint - Removal Information (GROUP 50, NO. 90-02)
- Wheels, Steel & Alloy - Paint Refinishing Procedure (GROUP 44, NO. 87-01)
Passive Restraints
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
Rear Suspension
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
- Upper Control Arm Bushings, Checking (GROUP 40, NO. 88-01)
- Suspension Components - Wax Coating Cavities (GROUP 40, NO. 87-01)
- Front Suspension - New Lower Control Arm & Strut Bar (GROUP 40, NO. 85-01)
Restraints Control Systems
- Sensor Checking (TT 97-06-64)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Seats
- Front Seat Cover Beading/Piping Visible (GROUP 74, NO. 91-02)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Automatic 3-Point Left Center Seat Belt, Retrofit (GROUP 68, NO. 91-04)
- Automatic Rear 3-Point Seat Belts, Retrofit Install (GROUP 68, NO. 91-02)
- Inspection Procedure For Complete Seat Belt System (GROUP 68, NO. 85-02)
- Rear Bench Seat Belts - Belt Buckle Cover Broken (GROUP 68, NO. 84-01)
Starter
- New Vas 6161 Battery Tester (TT 27-10-02)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Avoiding Unnecessary Battery Replacement (GROUP 27, NO. 93-10)
- Installation Of Electrical Aftermarket Equipment (GROUP 91, NO. 93-02)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- Engine Cranks Too Slowly/Won't Crank - Battery Cable (GROUP 97, NO. 87-05)
- Engine Does Not Crank/Battery Repeatedly Discharged (GROUP 27, NO. 87-06)
- Battery Charging - Minimum Charging Rates (GROUP 27, NO. 85-04)
- Recharging Maintenance-Free Batteries In Stock (GROUP 27, NO. 85-02)
Steering Column
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
Steering Control Systems
- Sensor Checking (TT 97-06-64)
Steering Gear
- Power Steering - Instructions For R & I & Repair (GROUP 48, NO. 84-02)
Steering Linkage
- Steering Knuckle Modification, Prevent Interference (GROUP 40, NO. 92-01)
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Coil Spring - Installation Position (GROUP 42, NO. 89-01)
- Front Suspension - New Lower Control Arm & Strut Bar (GROUP 40, NO. 85-01)
Sun Roof/T-Top/Convertible Top
- Lost/Broken Keys - Key Code Locations On Door Handle (GROUP 57, NO. 87-03)
- Correct Installation Of Outside Sliding Door Handle (GROUP 58, NO. 85-01)
Suspension Control Systems
- Sensor Checking (TT 97-06-64)
System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- Customer States, "Vehicle Hesitates Or Will Not Move After Stopping" (GROUP 01, NO. 01-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Lack Of Power After Extended Drive (DIGIFANT Engine) (GROUP 24, NO. 93-07)
- Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-02)
- DRIVEABILITY Complaints/Water Cooled VANAGONS (GROUP 24, NO. 92-02)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- 1.9L/2.1L WATERBOXER - Cylinder Head Reseal (GROUP 15, NO. 15-90-T01)
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- Ignition Related Engine Miss: New Ignition Connector (GROUP 28, NO. 90-02)
- P.I. 2082 - Accelerator Cable Change (GROUP 20, NO. 90-01)
- Throttle Body - Replacement (GROUP 24, NO. 90-03)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
- Hall Sensor Ignition Kit Parts Information (GROUP 28, NO. 89-01)
- Oil Cooler Seal Leaks In Extreme Cold (GROUP 17, NO. 87-05)
- Oil Leak From Rear - Oil Pump Gasket (GROUP 17, NO. 87-04)
- Water Cooled Engine Stalls/Misses Intermittently (GROUP 97, NO. 87-07)
- Coolant Temperature Gauge Light Flashes (GROUP 90, NO. 87-03)
- Engine Cranks Too Slowly/Won't Crank - Battery Cable (GROUP 97, NO. 87-05)
- Engine Does Not Crank/Battery Repeatedly Discharged (GROUP 27, NO. 87-06)
- Engine Stops Running - Ignition Control Unit (GROUP 28, NO. 87-05)
- Miss,Rough Idle/Part Load - Plug Connector/Dist Cap (GROUP 28, NO. 87-04)
- Ignition Distributor Trigger Wheel Removal (GROUP 28, NO. 87-01)
- Ignition System - Ignition Cable Removal (GROUP 28, NO. 86-08)
- Catalytic Converter - Checking/Replacement Procedure (GROUP 26, NO. 85-03)
- Fuel Injection System - Throttle Valve Check/Adjust (GROUP 24, NO. 85-01)
- Ignition System - New Ignition Cable Connectors (GROUP 28, NO. 85-01)
Towing
- Towing Information For Long Distance & Emergency (GROUP 01, NO. 85-02)
Transfer Case
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Knocking Noise From Rear CV Joint (GROUP 42, NO. 87-01)
Transmission Control Systems
- Sensor Checking (TT 97-06-64)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
Vacuum Pumps/Lines/Tanks/Water Trap
- Rough Idle/Engine Stalls - Loose Air Intake Boot (GROUP 24, NO. 24-90-T01)
Wheel Alignment
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Wheels & Tire System
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Vehicle Pulls/Drifts To One Side - Rotate Tires (GROUP 44, NO. 94-01)
- Wheels/Tires, Eliminating Vibrations - Information (GROUP 44, NO. 94-03)
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Steering Knuckle Modification, Prevent Interference (GROUP 40, NO. 92-01)
- Aerosol Tire Inflator/Sealer - Flammability Hazard (GROUP 44, NO. 91-02)
- Tire Rotation/Wear Diagnosis/Information (GROUP 44, NO. 90-06)
- Tire Rotation Policy (GROUP 44, NO. 88-01)
- Wheels, Steel & Alloy - Paint Refinishing Procedure (GROUP 44, NO. 87-01)
- Front Suspension - New Lower Control Arm & Strut Bar (GROUP 40, NO. 85-01)
Window Motors & Regulators
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Lost/Broken Keys - Key Code Locations On Door Handle (GROUP 57, NO. 87-03)
- Vent Window Sticks To Weatherstrip (GROUP 64, NO. 87-03)
- Correct Installation Of Outside Sliding Door Handle (GROUP 58, NO. 85-01)
- Sliding Window - Replacing Sliding Window Guides (GROUP 64, NO. 85-01)
Wiper/Washer Systems
- Windshield Wiper Blades Skipping (GROUP 92, NO. 95-02)
- Windshield Wiper Arm Angle Adjust Using Tool Us 9201 (GROUP 92, NO. 90-02)
- Windshield Wiper Blade Smearing (GROUP 92, NO. 90-01)
- Windshield Wiper Blades Streak Or Smear Windshield (GROUP 92, NO. 87-01)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring Harness Repairing (TT 97-01-23)
- Engine Cranks Too Slowly/Won't Crank - Battery Cable (GROUP 97, NO. 87-05)