LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Suzuki >> 2006 >> XL-7 Base, RWD, Standard >> Repair and Diagnosis (Single Page) >> Engine Performance >> System >> Engine General Information And Diagnosis >> Diagnostic Information and Procedures >> DTC P0117: Engine Coolant Temperature Circuit Low >> DTC Troubleshooting
April 5, 2026: LEMON Manuals is launched! Read the announcement.

DTC Troubleshooting

DTC DIAGNOSTIC TROUBLESHOOTING CHART

Step Action YES NO
1  Was "Engine and Emission Control System Check" performed?  Go to Step 2. Go to ENGINE AND EMISSION CONTROL SYSTEM CHECK .
2  Check ECT sensor and its circuit 
  1. Connect scan tool with ignition switch turned OFF.
  2. Turn ON ignition switch.
  3. Check engine coolant temp. displayed on scan tool.

Is 164 °C (327 °F) indicated? 		 Go to Step 3. Intermittent trouble. Check for intermittent referring to INTERMITTENT AND POOR CONNECTION INSPECTION .
3  Check wire harness 
  1. Disconnect ECT sensor connector with ignition switch turned OFF.
  2. Check engine coolant temp. displayed on scan tool.

Is -40 °C (-40 °F) indicated? 		 Replace ECT sensor. "GRN" circuit shorted to ground. If wire is OK, substitute a known-good ECM and recheck.
scientia non olet · About LEMON Manuals