LEMON Manuals: Even more car manuals for everyone: 1960-2025
Home >> Suzuki >> 2002 >> XL-7 Plus >> Repair and Diagnosis >> External Pages >> Different car >> Section 140 (Manual HVAC System) >> Repair Instructions. >> Compressor Removal & Installation >> Removal
April 5, 2026: LEMON Manuals is launched! Read the announcement.

Compressor Removal & Installation: Removal

WARNING: This page is about a different car, the 2003 Suzuki Vitara, 2003 Suzuki Grand Vitara, 2002 Suzuki Vitara, and 2002 Suzuki Grand Vitara. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
  1. Run engine at idle with A/C ON for 10 minutes.
  2. Disconnect negative cable at battery.
  3. Recover refrigerant from refrigeration system using recovery and recycling equipment.
    NOTE: The amount of compressor at removed must be measured and the same amount must be poured when Installing the compressor.
  4. Disconnect thermal protector lead wire.
  5. Disconnect suction and discharge hoses from compressor.
    NOTE: Cap open fitting immediately to keep moisture out of system.
  6. Remove generator belt. See GENERATOR BELT .
  7. Remove compressor with clutch assembly from its mount.
  8. If compressor assembly is replaced. Drain oil from compressor, and measure its amount.
scientia non olet · About LEMON Manuals