Specifications Index
SPECIFICATIONS INDEX
| System | Specification/Procedure | |
|---|---|---|
| Air Conditioning | ||
| Service | CAPACITIES & SPECIFICATIONS | |
| Torque | TORQUE SPECIFICATIONS | |
| Axle Nut/Hub Nut (Collar Nut) | ||
| Front | See applicable components in FRONT AXLE SHAFT | |
| Rear | REAR AXLE SHAFT | |
| Battery | TEST VALUES FOR BATTERY, VOLTAGE SUPPLY | |
| Brakes | ||
| Bleeding Sequence | CARRYING OUT BLEEDING OPERATION | |
| Disc Brakes | TEST & ADJUSTMENT VALUES | |
| Torque | TORQUE SPECIFICATIONS | |
| Charging | ||
| Generator | TEST SPECIFICATIONS OF INTEGRATED STARTER ALTERNATOR | |
| Torque | INTEGRATED STARTER ALTERNATOR | |
| Drive Belts | ||
| Adjustment |
NOTE:
Engine 256.930 uses an Electric AC Compressor and Integrated Starter/Alternator and use no drive belts
|
|
| Belt Routing |
NOTE:
Engine 256.930 uses an Electric AC Compressor and Integrated Starter/Alternator and use no drive belts
|
|
| Engine Cooling | ||
| General Service Specifications | CAPACITIES & SPECIFICATIONS | |
| Radiator Cap Pressure | CHECK VALUES FOR COOLING SYSTEM CAP | |
| Thermostat R & I | REMOVE/INSTALL COOLANT THERMOSTAT | |
| Water Pump R & I | REMOVE/INSTALL ELECTRIC COOLANT PUMP | |
| Engine Mechanical | ||
| Compression | COMPRESSION PRESSURE | |
| Oil pressure | OIL PRESSURE | |
| Overhaul | COMPLETE ENGINE - TEST & ADJUSTMENT VALUE
--> ............................................................................... ENGINE TIMING - TEST & ADJUSTMENT VALUES --> ............................................................................... CRANK ASSEMBLY - TEST & ADJUSTMENT VALUES --> |
|
| Torque | COMPLETE ENGINE - TORQUE SPECIFICATIONS
--> ............................................................................... ENGINE TIMING - TORQUE SPECIFICATIONS --> ............................................................................... CRANK ASSEMBLY - TORQUE SPECIFICATIONS --> |
|
| Flywheel/Flex Plate Torque | FLYWHEEL, DRIVEN PLATE, VIBRATION DAMPER, STARTER RING GEAR | |
| Fuel System | ||
| Fuel Filter Location | Fuel filter is integrated into the fuel pump, see REMOVE/INSTALL FUEL PUMP | |
| Fuel Filter R & I | REPLACE FUEL FILTER | |
| Pressure Release Procedure | RELIEVE FUEL PRESSURE REDUCE FUEL PRESSURE THROUGH SERVICE VALVE |
|
| Pressure Specification | N/A | |
| Fuel Pressure Test Procedure | CHECK FUEL HIGH PRESSURE CIRCUIT | |
| Ignition | ||
| Firing Order | FIRING ORDER & CYLINDER IDENTIFICATION | |
| Ignition Wires (Routing) | Coil on plug | |
| Spark Plug | ||
| Gap | SPARK PLUGS | |
| Torque | IGNITION SYSTEM | |
| Starting | ||
| Starter | REMOVE/INSTALL INTEGRATED STARTER ALTERNATOR | |
| Torque | INTEGRATED STARTER ALTERNATOR | |
| Wheel Alignment | ||
| Adjustment Specifications | TEST & ADJUSTMENT VALUES | |
| Torque | see PERFORM WHEEL ALIGNMENT CHECK | |
| Wheel & Tire | ||
| Wheel Lug Nut Torque | WHEELS | |