Engine Controls - Tests W/Codes
- Introduction
- Self-Diagnostic System
- System Diagnosis
- System Diagnosis Description
- Hard Failures
- Intermittent Failures
- Pretest Inspection
- Entering On-Board Diagnostics (Using Voltmeter)
- Diagnostic Procedure (Using DRB-II)
- Entering On-Board Diagnostics (Using DRB-II)
- DRB-II Error Screens
- System Fault ROM Check Sum XXXX Message
- System Fault Keyboard Failure Message
- System Fault ROM Failure XXXX
- System Fault EEPROM Failure
- System Failure, Communication Failure, Refer To Diagnostic Procedures Message
- SYSTEM FAILURE NO RESPONSE FROM ADAPTER or SYSTEM FAILURE ADAPTER REQUIRED TO DIAGNOSE WITH THIS CARTRIDGE MESSAGE
- Fault Codes
- Clearing Codes
- Test Charts - 1.5L
- Notes
- NS-1: Testing Ignition Circuit
- NS-2: Checking For Fuel Pressure
- NS-3: Testing Fuel Pump Circuit
- NS-4: Testing Self-Diagnostic Connector
- NS-5: Testing Crank Angle Sensor Circuit
- NS-6: Testing Control Relay
- Dr-1: Checking For Fault Codes
- Dr-2: Code 11 Oxygen Sensor Circuit
- Dr-3: Code 12 Airflow Sensor Circuit
- Dr-4: Code 13 Intake Air Temperature Sensor Circuit
- Dr-5: Code 14 Throttle Position Sensor Circuit
- Dr-6: Code 15 Motor Position Sensor Circuit
- Dr-7: Code 21 Coolant Temperature Sensor Circuit
- Dr-8: Testing Self-Diagnostic Connector
- Dr-9: Code 23 Top Dead Center Sensor Circuit
- Dr-10: Code 24 Vehicle Speed Sensor Circuit
- Dr-11: Code 25 Barometric Pressure Sensor Circuit
- Dr-12: Code 41 Injector Circuit
- Dr-13: Code 42 Fuel Pump Circuit
- Dr-14: Code 43 EGR Temperature Sensor Circuit
- Dr-15: No Fault Code Testing
- Dr-16: No Fault Code Sensor Test
- Dr-17: Testing Purge Solenoid Circuit
- Dr-18: No Fault Code Mechanical Test
- Test Charts - 1.6L
- NS-1: Testing Ignition Circuit
- NS-2: Testing Crank Angle Sensor Circuit
- NS-3: Testing Fuel System
- NS-4: Testing Fuel Pump Circuit
- NS-5: Testing Control Relay Circuit
- NS-6: Testing Self-Diagnostic Connector
- Dr-1: Checking For Fault Codes
- Dr-2: Fault Code Tests
- Dr-3: Code 11 Oxygen Sensor Circuit
- Dr-4: Code 12 Airflow Sensor Circuit
- Dr-5: Code 13 Intake Air Temperature Sensor Circuit
- Dr-6: Code 14 Throttle Position Sensor Circuit
- Dr-7: Code 21 Coolant Temperature Circuit
- Dr-8: Code 22 Crank Angle Sensor Circuit
- Dr-9: Code 23 Top Dead Center Sensor Circuit
- Dr-10: Code 24 Vehicle Speed Sensor Circuit
- Dr-11: Code 25 Barometric Pressure Sensor Circuit
- Dr-12: Code 41 Injector Circuit
- Dr-13: Code 42 Fuel Pump Circuit
- Dr-14: Code 43 EGR Temperature Sensor Circuit
- Dr-15: Code 44 Ignition Coil Circuit
- Dr-16: No Fault Code Tests
- Dr-17: No Fault Code Sensor Tests
- Dr-18: No Fault Code Fuel Pressure Test
- Dr-19: No Fault Code EGR System Test - 1.6L
- Dr-20: No Fault Code Purge Control Circuit Test
- Dr-21: No Fault Code Mechanical Test
- NS-VER: No Start Verification Procedure
- Dr-VER: DRIVEABILITY Verification Procedure
- Test Charts - 1.8L
- NS-1: Testing Ignition Circuit
- NS-2: Testing For Fuel
- NS-3: Code 42 Fuel Pump Circuit
- NS-4: Testing Diagnostic Connector
- NS-5: Code 22 Crank Angle Sensor
- NS-6: Testing Control Relay
- Dr-1: Checking For Fault Codes
- Dr-2: Code 11 Oxygen Sensor Circuit
- Dr-3: Code 12 Airflow Sensor Circuit
- Dr-4: Code 13 Intake Air Temperature Sensor Circuit
- Dr-5: Code 14 Throttle Position Sensor Circuit
- Dr-6: Code 15 Motor Position Sensor Circuit
- Dr-7: Code 21 Coolant Temperature Sensor Circuit
- Dr-8: Testing Diagnostic Connector
- Dr-9: Code 23 Top Dead Center Sensor Connector
- Dr-10: Code 24 Vehicle Speed Sensor Circuit
- Dr-11: Code 25 Barometric Pressure Sensor Circuit
- Dr-12: Code 41 Injector Circuit
- Dr-15: No Fault Code Testing
- Dr-16: No Fault Code Sensor Test
- Dr-17: Purge Solenoid
- Dr-18: No Fault Code Mechanical Test
- Test Charts - 2.0L
- NS-1: Ignition Check Flow Charts
- NS-2: Checking Crank Angle Sensor
- NS-3: Fuel Test
- NS-4: Checking Fuel Pump Operation
- NS-5: Checking Control Relay Circuit
- NS-VER: No Start Verification Test
- Dr-1: Fault Code Check
- Dr-2: Checking Oxygen Sensor
- Dr-3: Checking Airflow Sensor - Turbo
- Dr-4: Checking Airflow Sensor - Non-Turbo
- Dr-5: Checking Intake Air Temp Sensor - Turbo
- Dr-6: Checking Intake Air Temp Sensor - Non-Turbo
- Dr-7: Checking Throttle Position Sensor (TPS)
- Dr-8: Checking Coolant Temperature Sensor (Cts)
- Dr-9: Checking Crank Angle Sensor
- Dr-10: Checking TDC Sensor
- Dr-11: Checking Vehicle Speed Sensor
- Dr-12: Checking Barometric Pressure Sensor - Turbo
- Dr-13: Checking Barometric Pressure Sensor - Non-Turbo
- Dr-14: Checking Detonation Sensor
- Dr-15: Checking Injector Circuit
- Dr-16: Checking Fuel Pump Control Circuit
- Dr-17: Testing EGR Temperature Sensor Circuit
- Dr-18: Checking Ignition Coil Circuit
- Dr-19: No-Fault Code, DRB-II ATM Not Running Test
- Dr-20: No-Fault Code, DRB-II Switches Not Running Test
- Dr-21: No-Fault Code Test, DRB-II Sensor Test
- Dr-22: No-Fault Code Mechanical Test
- Dr-VER: DRIVEABILITY Verification Test
- Summary