Section 41 (Wire And Connector Repair)
WARNING: This page is about a different car, the 2020 Cadillac CT4. However, it is still accessible from the selected car via links, so may be relevant.
- Diagnostic Information and Procedures
- General Electrical Diagnosis
- Checking Aftermarket Accessories
- Using Connector Test Adapters
- Probing Electrical Connectors
- Troubleshooting with a Digital Multimeter
- Troubleshooting with a Test Lamp
- Using Fused Jumper Wires
- Measuring Voltage
- Measuring Voltage Drop
- Measuring Frequency
- Testing Ground and Low Reference Circuits
- Testing for Continuity
- Testing for Short to Ground
- Testing for a Short to Voltage
- Inducing Intermittent Fault Conditions
- Testing for Electrical Intermittents
- Scan Tool Snapshot Procedure
- Circuit Protection - Fuses
- Circuit Protection - Circuit Breakers
- Circuit Protection - Fusible Links
- Sealed Weather Pack Connector Cleaning
- Repair Instructions
- Repairing Damaged Wire Insulation
- Coaxial Cable Repairs
- Flat Wire Repairs
- Folded-Over Wire Repair
- Serial Data Circuit Wiring Repairs
- Heated Oxygen Sensor Wiring Repairs
- High Temperature Wiring Repairs
- SIR/SRS Wiring Repairs
- Splicing Inline Harness Diodes
- Splicing Twisted or Shielded Cable
- Wire to Wire Repair
- Connector Position Assurance Locks
- Terminal Position Assurance Locks
- AFL/EPC Connectors
- Bosch Connectors (0.64)
- Bosch Connectors (BSK)
- Bosch Connectors (2.8 JPT)
- Bosch Connectors (ECM)
- Delphi Connectors (Weather Pack)
- Delphi Connectors (Push to Seat)
- Delphi Connectors (Pull to Seat)
- Delphi Connectors (Micro Pack 100W)
- Delphi Connectors (Micro.64)
- Delphi Connectors (12-Way)
- Delphi Connectors (Steering Gear)
- FCI Connectors (Lever Lock)
- FCI Connectors (SIR)
- FEP Connectors (Steering Gear)
- JST Connectors
- Kostal Connectors (Glow Plug Control Module)
- Kostal Connectors (Transmission)
- Molex Connectors (Lever Lock)
- Molex Connectors (SIR)
- Sumitomo Connectors
- Tyco/AMP Connectors (CM 42-Way)
- Tyco/AMP Connectors (Sensor)
- Tyco/AMP Connectors (0.25 Cap)
- Tyco/AMP Connectors (43-Way)
- Tyco/AMP Connectors (Door Module)
- Tyco/AMP Connectors (Seat)
- Tyco/AMP Connectors (102-Way Inline)
- Tyco/AMP Connectors (SIR)
- Yazaki Connectors (2-Way)
- Yazaki Connectors (16-Way)
- Repairing Connector Terminals (Terminated Lead Repair)
- Repairing Connector Terminals (Terminal Repair)
- Terminal Removal
- 0.5 NANO, 1.2 MCON Series Connectors
- 0.64 Micro-Quadlock Series Connectors
- 0.64 OCS Series Connectors
- 0.64 GEN-Y, 1.2 MCON Series, Sealed Connectors (Female)
- 0.64, 2.8 Series, Sealed Connectors (Female)
- 0.64 MTS, 6.3 MCP Series Connectors (Female)
- 90-way F 0.64 GEN-Y, 2.8, 6.3 MCP Series, Sealed Connectors (Female)
- 1.2 MCON-CB Series, Sealed Connectors (Female)
- 1.2, 1.5, 2.8 YESC Series Connectors (Female)
- 1.2, 2.8 Multiple Contact Point Series Connectors (Female)
- 1.2, 2.8 Multiple Contact Point Series Connectors (Male)
- 1.2 OCS, 2.8, 4.8 CTS Series, Sealed Connectors (Female)
- 1.5, 2.8 Series, Sealed Connectors (Male)
- 1.5, 2.8 Series, Sealed Connectors (Female)
- 1.2 MCON-CB, 2.8 MCP Series, Sealed Connectors
- 1.5, 2.8, 4.8 MCP Series, Sealed Connectors
- Mini 50 Series Connectors
- 150 Metri-Pack Series Connectors (Female)
- 150 MX Sealed Series Connectors (Female)
- Ground Repair