October 30: LEMON manuals on a temporary server, it is slow and having issues, download the manuals you need! Later in November we will switch back to the fast server.
Technical Service Bulletins Expand All (for easy ctrl-f) Collapse All A/C Compressor Accessories Control Systems Accessory Drive Belts Air Bag, SRS Anti-Lock Brakes Anti-Theft Systems Automatic Trans New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01) Trans. Oil Seals, Lubrication Prior To Installation (GROUP 34, NO. 96-01) Trans. Oil Seals, Lubrication Prior To Installation (GROUP 39, NO. 96-02) Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02) Automatic Transmission Identification (GROUP 37, NO. 95-01) Harsh Shifting With 097 Trans - Clean TPS Sensor (GROUP 01, NO. 94-04) Transmission Control Module (T.C.M.) Mismatched (GROUP 37, NO. 94-02) ATF Oil Change Interval For 4 Speed Automatic Trans (A 94-02) Recommended Final Drive Oil Change (4-Speed A/T) (A93-01) Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01) 4-SPD Automatic Transmission 097 Erratic/Hard Shift (GROUP 37, NO. 93-04) A/T Final Drive Synthetic Oil Requirement (GROUP 37, NO. 93-02) Drive Plate Installing - Revised Eng/Trans Torques (GROUP 13, NO. 93-03) 4-Speed A/T Differential Oil Level Information (A93-10) Revised Engine/Transmission Tightening Torques (GROUP 37, NO. 92-09) Harsh Shifting/Transmission Goes Into Limp Mode (GROUP 37, NO. 91-08) ATF Filter Not Needed - Information (GROUP 37, NO. 91-09) 097 Transmission, Establishing Basic Setting (GROUP D3, NO. 91-02) Shift Console Light Replacement (GROUP 37, NO. 91-07) Auxiliary Emission Control Systems EGR Valve, Frequency Valve, Replacing (GROUP 26, NO. 96-01) Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01) Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02) Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01) Exhaust Gas RECIRCULATION - System Testing (GROUP 26, NO. 92-01) Rotten Egg Odor At Exhaust - Sulfur In Fuel (GROUP 24, NO. 92-04) Sensor Plate Potentiometer Checking & Adjusting (GROUP 25, NO. 92-03) Alternator Belt Slipping - Adjustment Procedure (GROUP 27, NO. 92-01) Excessive Cranking Time, Stalls After Starting (GROUP 25, NO. 92-01) Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12) Electrical Troubleshooting Steps (GROUP D2, NO. 91-01) Electronic Control Units - Precautions (GROUP 28, NO. 91-03) Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03) OBD System - 097 Transmission Equipped Vehicles (A 90-06) Axle Shafts Blowers, Superchargers & Turbochargers Body Interior Brakes Control Systems Charging Systems Clutch Communication Devices Cooling System (Mechanical) Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02) New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01) Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01) Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01) Engine Oil Leaks From The Front Of The Engine (GROUP 17, NO. 94-03) Coolant Circulation Pump Leakage Troubleshooting (GROUP 19, NO. 93-03) Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03) Antifreeze Testers - Accuracy Information (GROUP 19, NO. 91-02) Metal Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-05) VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08) VITON Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-04) Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02) Differentials & Drive Axles Driveshaft & Universal Joints Electronic Steering Electronic Suspension Engine Control Systems Portable Gasoline Containers Filling (GROUP 20, NO. 95-02) Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01) Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02) Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01) Engine Performance Problems & Possible Causes (GROUP 25, NO. 93-04) Sensor Plate Potentiometer Checking & Adjusting (GROUP 25, NO. 92-03) Excessive Cranking Time, Stalls After Starting (GROUP 25, NO. 92-01) Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12) Electrical Troubleshooting Steps (GROUP D2, NO. 91-01) Electronic Control Units - Precautions (GROUP 28, NO. 91-03) Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03) OBD System - 097 Transmission Equipped Vehicles (A 90-06) Entertainment Systems Exhaust Exterior Lights Frames, Subframes & Crossmembers Front Suspension Fuel System Fuses & Circuit Breakers Gauges & Instrument Panels General Servicing Headlights HVAC Control Systems Identification Ignition Switch/Steering Lock Ignition System Infotainment Interior/Exterior Trim Interior/Illumination Lights Locking Hubs Lubrication System Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02) New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01) Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01) Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02) Engine Oil Leaks From The Front Of The Engine (GROUP 17, NO. 94-03) Oil Consumption Explanation (GROUP 17, NO. 94-02) Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03) Metal Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-05) VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08) VITON Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-04) 5 CYL Eng - Check Engine Light On - Power Loss (GROUP 28, NO. 91-04) Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02) Manual Steering Manual Trans Mechanical All Models, Dynamic Compression Test Using DSO Function (CTT 00-14-01) Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02) Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01) Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-01) Engine Oil Leaks From The Front Of The Engine (GROUP 17, NO. 94-03) Oil Consumption Explanation (GROUP 17, NO. 94-02) Drive Plate Installing - Revised Eng/Trans Torques (GROUP 13, NO. 93-03) Generator V-Belt Replacement-Special Tool Available (GROUP 27, NO. 93-01) Revised Engine/Transmission Tightening Torques (GROUP 37, NO. 92-09) Metal Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-05) New Flywheel Mounting Bolts - Revised Torque (GROUP 13, NO. 91-04) VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08) VITON Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-04) Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02) Hydraulic Valve Lifters - Noisy (GROUP 15, NO. 91-03) Mechanical - Hydraulic Brake Pedal Pulsation/Steering Wheel Shimmy Checking (GROUP 46, NO. 98-01) Brake Squeal - Component Cleaning/Lubricant (GROUP 46, NO. 97-01) New Lifetime Coolant For All Aluminum Engines (GROUP 19, NO. 96-01) Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-02) Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01) Brake System - Bleeding Information (GROUP 47, NO. 93-02) Brake Master Cylinder Leaks - Revised Rubber Plugs (GROUP 47, NO. 92-07) Adapter VAG 1310/6 For Brake Pressure Regulator (GROUP 47, NO. 92-04) New Hydraulic Brake Servo - Installation Procedure (GROUP 47, NO. 92-02) Central Hydraulic System Replacement - Inspection (GROUP 48, NO. 88-05) High Temp Brake Fluid - Super Dot 4 Service Info (GROUP 47, NO. 91-02) Clicking Noise Inside Vehicle - Improved Damper Hose (GROUP 48, NO. 91-02) Don't Use Brake Dust Covers-Insufficient Ventilation (GROUP 46, NO. 91-04) Brake Fluid Change/Topping Off (GROUP 47, NO. 91-01) Mirrors Overdrive Unit Paint & Coatings Passive Restraints Rear Suspension Restraints Control Systems Schedule Seats Starter Steering Column Steering Column Switches Steering Control Systems Steering Linkage Sun Roof/T-Top/Convertible Top Suspension Control Systems System Engine Oil Seals, Lubrication Prior To Installation (GROUP 13, NO. 96-02) EGR Valve, Frequency Valve, Replacing (GROUP 26, NO. 96-01) Engine Oil Seals, Lubrication Prior To Installation (GROUP 15, NO. 96-01) Portable Gasoline Containers Filling (GROUP 20, NO. 95-02) Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-01) Electronic ECT Thermal Switch (F76) - Redesigned (GROUP 19, NO. 94-01) Heated Oxygen Sensor Contact Cleaner Precaution (GROUP 24, NO. 94-02) Oxygen Sensor Contamination Due To Silicone (GROUP 26, NO. 93-01) Vehicle DRIVEABILITY - Distributor Caps (GROUP 28, NO. 93-03) Vehicle DRIVEABILITY - Distributor Rotor (GROUP 28, NO. 93-04) Engine Performance Problems & Possible Causes (GROUP 25, NO. 93-04) Dynamic Oil Pressure System - Troubleshooting Tips (GROUP 17, NO. 92-03) Engine Misfire/Hard To Start - Ignition Cable Wires (GROUP 28, NO. 92-01) Exhaust Gas RECIRCULATION - System Testing (GROUP 26, NO. 92-01) Rotten Egg Odor At Exhaust - Sulfur In Fuel (GROUP 24, NO. 92-04) Sensor Plate Potentiometer Checking & Adjusting (GROUP 25, NO. 92-03) Excessive Cranking Time, Stalls After Starting (GROUP 25, NO. 92-01) Fault Code 2132 - Incorrect Fuel And/Or Ignition Ecu (GROUP 25, NO. 91-12) Electrical Troubleshooting Steps (GROUP D2, NO. 91-01) Metal Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-05) VITON Tipped Fuel Injector, Fuel Delivery Comparison (GROUP 25, NO. 91-08) VITON Tipped Fuel Injectors - Checking & Cleaning (GROUP 25, NO. 91-04) Front Crank Seal Removal Procedure (GROUP 13, NO. 91-02) Electronic Control Units - Precautions (GROUP 28, NO. 91-03) Vehicle Loses Power - Codes 2141, 2142, 2143 Stored (GROUP 28, NO. 90-03) OBD System - 097 Transmission Equipped Vehicles (A 90-06) Transmission Control Systems Vacuum Pumps/Lines/Tanks/Water Trap Warning Systems Wheel Hubs Wheels & Tire System Window Motors & Regulators Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)