Steering Column, Removing And Installing: Installing

-- Install the steering column -1- with the opening into the guide on the mounting bracket -arrow-.

Fig 1: Identifying Lowering Steering Column And Removing From Guide

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Only in This Way Is the Correct Installation Position of Steering Column to Mounting Bracket Guaranteed.

NOTE:

Always follow the bolt installation sequence when installing the steering column.

-- Secure the steering column with the bolt -1-.

Fig 2: Identifying Bolt

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the brake pedal crash bolster -2- and secure it with the bolt -1-.

Fig 3: Identifying Brake Pedal Crash Bolster & Mounting Bolts

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Vehicles with a DSG ^® Transmission and Automatic Transmission

Fig 4: Identifying Bolt

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Secure the steering column with the bolt -1-.

Vehicles with Manual Transmission

Fig 5: Identifying Clutch Pedal Crash Bolster With Bolt

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the clutch pedal crash bolster -2- and secure it with the bolt -1-.

Continuation for All Vehicles

-- Tighten the bolts -1 through 4- one after the other to the tightening specification.

Fig 6: Identifying Steering Column Bolts

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the cable guide -1- under the steering column.

Fig 7: Identifying Cable Guide

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Tabs -arrow- must engage into guide on both sides.

-- Attach the ground cable to the steering column -arrow-.

Fig 8: Identifying Ground Wire And Nut

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install the universal joint -1- on the steering pinion in direction of -arrow-.

Fig 9: Installing Universal Joint

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Install and tighten the new bolt -arrow-.

-- Install the cover -2- and tighten the bolts -1-.

Fig 10: Identifying Footwell Trim Panel

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Vehicles with Ignition Switch

-- Connect the connector -1-.

Fig 11: Identifying Ignition Switch Connector

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

Vehicles with "Keyless Access" Keyless Locking and Starting System

-- Connect the connector -1-.

Fig 12: Identifying "Keyless Access" Keyless Locking And Starting System Connector

Courtesy of VOLKSWAGEN GROUP OF AMERICA, INC.

-- Clip the wire into the retainer on the Electronic Steering Column Lock Control Module -J764- -arrow-.

Continuation for All Vehicles

-- Install the steering column switch module. Refer to OVERVIEW - STEERING COLUMN SWITCH MODULE .

-- Install the lower steering column trim panel. Refer to LOWER STEERING COLUMN TRIM PANEL, REMOVING AND INSTALLING .

-- Install the upper steering column trim panel. Refer to UPPER STEERING COLUMN TRIM PANEL, REMOVING AND INSTALLING .

-- Install the steering wheel. Refer to STEERING WHEEL, REMOVING AND INSTALLING .

-- Install the driver side airbag unit. Refer to AIRBAG UNIT WITH IGNITER, REMOVING AND INSTALLING .

-- Perform a basic setting on the Steering Angle Sensor -G85-. Refer to Vehicle Diagnostic Tester.