Abs Mark 60 EC (Abs/EDL/ASR/Esp) Component Overview
WARNING: This page is about a different car, the 2014 Volkswagen Jetta, 2013 Volkswagen Jetta, 2012 Volkswagen Jetta, 2011 Volkswagen Jetta, and 2010 Volkswagen Jetta. However, it is still accessible from the selected car via links, so may be relevant.
- ABS Control Module (w/EDL) -J104-
- Component location: At hydraulic unit on right side of engine compartment.
- Do not disconnect connector before successfully completing On Board Diagnostic (OBD). Switch ignition off before separating connector.
The following components are integrated inside the control module:
- Sensor for Transverse Acceleration -G200-
- Rotation Rate Sensor -G202-
- Longitudinal Acceleration Sensor -G251- (depending on the vehicle equipment level)
- Removal and installation, refer to CONTROL MODULE AND HYDRAULIC UNIT, REMOVING .
- ABS Hydraulic Unit -N55-
- Component location: in engine compartment, right.
The hydraulic unit consists of the components:
- ABS Hydraulic Pump -V64-
- Brake Pressure Sensor -G201-
- Valve block (contains the in/outlet valves)
- The ABS hydraulic pump and valve block must not be separated from one another.
- Removal and installation, refer to CONTROL MODULE AND HYDRAULIC UNIT, REMOVING .
- Component location: in engine compartment, right.
- Brake Pad Wear Indicator Lamp -K32-
- Component location: In the instrument cluster.
- Function, refer to ABS/EDL/ASR/ESP INDICATOR LAMPS .
- ABS Warning Lamp -K47-
- Component location: In the instrument cluster.
- Function, refer to ABS/EDL/ASR/ESP INDICATOR LAMPS .
- ASR/ESP Control Lamp -K155-
- Only on vehicles with ABS/EDL/ASR/ESP.
- Component location: In the instrument cluster.
- Function, refer to ABS/EDL/ASR/ESP INDICATOR LAMPS .
- Brake System Warning Lamp -K118-
- Component location: In the instrument cluster.
- Function, refer to ABS/EDL/ASR/ESP INDICATOR LAMPS .
- Brake Light Switch -F-
- Includes Brake Pedal Switch -F47-
- Component location: On brake master cylinder.
- Removal and installation, refer to BRAKE LIGHT SWITCH .
- ASR/ESP Button -E256-
- Only on vehicles with ABS/EDL/ASR/ESP.
- Component location: in center console.
- Diagnostic Connection
- Component location: cover in driver footwell.
- Steering Angle Sensor -G85-NOTE:
The steering angle sensor is installed inside the steering gear on vehicles with generation 3 electro-mechanical steering.
- Component location: inside the steering gear.
- Removal and installation, refer to STEERING ANGLE SENSOR .
- Right Front ABS Wheel Speed Sensor -G45- /Left Front ABS Wheel Speed Sensor -G47-
- Removal and installation, refer to ABS SYSTEM COMPONENTS AT FRONT AXLE ASSEMBLY OVERVIEW .
- Wheel Bearing Unit
- The ABS sensor ring is installed in the wheel bearing.
- Right Rear ABS Wheel Speed Sensor -G44- /Left Rear ABS Wheel Speed Sensor -G46-
- Removal and installation, FWD, refer to ABS SYSTEM COMPONENTS AT REAR AXLE ASSEMBLY OVERVIEW, FWD .
- Removal and installation, AWD, refer to ABS SYSTEM COMPONENTS ON REAR AXLE ASSEMBLY OVERVIEW, AWD .
- Wheel Hub with Wheel Bearing
- The ABS sensor ring is installed in the wheel bearing.