Passenger Compartment CLIMATRONIC
WARNING: This page is about a different car, the 2011 Volkswagen Eos, 2010 Volkswagen Eos, 2009 Volkswagen Eos, 2008 Volkswagen Eos, and 2007 Volkswagen Eos. However, it is still accessible from the selected car via links, so may be relevant.
NOTE:
Disconnect the battery before removing components marked with a **. Refer to Removal and Installation .
A data plate on the lock carrier indicates the refrigerant used and capacity.
- Dash Panel **
- Removing and installing, refer to Removal and Installation .
- Sunlight Photo Sensor -G107- or Sunlight Photo Sensor 2 -G134-
- Checking: use the Vehicle Diagnostic Tester.
- Controls temperature door and fresh air blow depending on light intensity.
- Emergency running in the event of failure: the Climatronic control module -J255- utilizes a fixed value.
- Removing and installing, refer to SUNLIGHT PHOTO SENSORS -G107- / -G134- .
- Center Vents
- Removing, refer to CENTER VENT .
- Air Outlet
- Removing, refer to DRIVER AND PASSENGER SIDE VENTS .
- Right Vent Temperature Sensor -G151-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to RIGHT VENT TEMPERATURE SENSOR -G151- .
- Front A/C Display Control Head -E87- with Climatronic Control Module -J255-, Through 18 May 2008
- The Climatronic Control Module and the Front A/C Display Control Head are one component that cannot be disassembled.
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to FRONT A/C DISPLAY CONTROL HEAD -E87- / -J255- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Front A/C Display Control Head -E87- with Climatronic Control Module -J255-, From 25 May 2008
- The Climatronic Control Module and the Front A/C Display Control Head are one component that cannot be disassembled.
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to FRONT A/C DISPLAY CONTROL HEAD -E87- / -J255- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Air Flow Door Motor -V71-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to AIR FLOW DOOR MOTOR -V71- WITH BACK PRESSURE DOOR MOTOR POSITION SENSOR -G113- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Recirculation Door Motor -V113-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to FRESH/RECIRCULATING AIR DOOR MOTOR -V154- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Right Footwell Vent
- Removing and installing, refer to RIGHT FOOTWELL VENT .
- Fresh Air Blower -V2- with Fresh Air Blower Control Module -J126- NOTE:
The fresh air blower control module and the fresh air blower are in a single housing together and cannot be replaced individually.
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to FRESH AIR BLOWER -V2- / FRESH AIR BLOWER CONTROL MODULE -J126- .
- Connector
- Heating Unit Partition
- Removing, refer to "Partition" under FRESH AIR BLOWER -V2- .
- Cap
- Only in vehicles without air duct to vent installed in center console at rear.
- Dust and Pollen Filter
- With EVAP canister.
- Removing and installing, refer to DUST AND POLLEN FILTER .
- Air Outlet Grille
- Rear Channel For Right Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Rear Channel For Left Footwell
- Removing and installing, refer to REAR FOOTWELL CHANNEL .
- Evaporator Vent Temperature Sensor -G263- or Evaporator Temperature Sensor -G308-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to EVAPORATOR VENT OR EVAPORATOR TEMPERATURE SENSOR -G263- / -G308- .
- Right Temperature Door Motor -V159-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to RIGHT TEMPERATURE DOOR MOTOR -V159- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Heater Core
- Removing and installing, refer to HEATER CORE .
- Auxiliary Heater Heating Element -Z35-
- Only installed on vehicles with Diesel engine.
- Central Air Door Motor -V70-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to CENTRAL AIR DOOR MOTOR -V70- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Left Footwell Vent
- Removing and installing, refer to LEFT FOOTWELL VENT .
- Left Temperature Door Motor -V158-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to LEFT TEMPERATURE DOOR MOTOR -V158- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Left Footwell Vent Temperature Sensor -G261-
- Checking: use the Vehicle Diagnostic Tester.
- Removing, refer to LEFT FOOTWELL VENT TEMPERATURE SENSOR -G261- .
- Defroster Door Motor -V107-
- Checking: use the Vehicle Diagnostic Tester.
- Removing and installing, refer to DEFROSTER DOOR MOTOR -V107- .
- Replacing: perform a basic setting using the Vehicle Diagnostic Tester. Refer to CHECKING AND ADJUSTING COMPONENTS .
- Heating and A/C Unit
- Removing and installing, refer to HEATING AND A/C UNIT .
- Disassembling and assembling, refer to CLIMATRONIC HEATER AND A/C UNIT .
- Right Footwell Vent Temperature Sensor -G262-
- Checking: use the Vehicle Diagnostic Tester.
- Removing, refer to RIGHT FOOTWELL VENT TEMPERATURE SENSOR -G262- .
- Left Vent Temperature Sensor -G150-
- Checking: use the Vehicle Diagnostic Tester.
- Removing, refer to RIGHT VENT TEMPERATURE SENSOR -G151- .