Technical Service Bulletins

A/C Compressor
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- A/C Compressor Clutch, Removing & Installing (GROUP 87, NO. 91-04)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
Accessories & Equipment
- New Vas 6161 Battery Tester (TT 27-10-02)
Accessories Control Systems
- Sensor Checking (TT 97-06-64)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Accessory Drive Belts
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Alternator Light On, V Belt Squeals When Wet (GROUP 13, NO. 92-02)
- V-Belt Squealing - Checking & Adjusting (GROUP 13, NO. 89-02)
Air Bag, SRS
- 69-19-01 - Airbag/Pyrotechnic Safety Belt Deployment Inquiries (U.S. Only) (GROUP 69, NO. 97-07)
Anti-Lock Brakes
- Abs/EDL On-Board Diagnostic, DTC Memory Analysis (GROUP 01, NO. 92-01)
- Abs Pump Supersession Information (GROUP 45, NO. 91-01)
Anti-Theft Systems
- Radio, Anti-Theft Radio Security Code Retrieval Procedures (GROUP 91, NO. 05-02)
- Alarm System Control Module Location (GROUP 90, NO. 93-03)
- Front Power Window Glass Comes Out Of Track (GROUP 64, NO. 91-04)
- Door Lock Cylinder Jams - New Lock Carrier Available (GROUP 57, NO. 91-03)
- Ball Latch In Door Handle Discontinued (GROUP 57, NO. 91-02)
- Lock Cylinder Installation - Outer Door Handle (GROUP 57, NO. 90-01)
Automatic Trans
- Transmission Replacements (TT 37-08-01)
- Transmission Fluid (TT 38-07-97)
- Transmission Code Identification (TT 37-06-12)
- Automatic Transmission, Repairing (GROUP 37, NO. 05-01)
- Torque Converter With Needle Bearing, Installing On Transmission With Bushing On Turbine Shaft (GROUP 32, NO. 00-01)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Ag4 Automatic Transmissions, Fault 00652 Repair (TT 37-98-25)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Ag4 Automatic Transmission - Fault 00293 (TT 37-97-13)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- 096/098 Automatic TRANSMISSSION Troubleshooting (GROUP 37, NO. 94-02)
- A/T Valve Body Replacement: New Valve Body & Oil Pan (GROUP 38, NO. 93-04)
- Checking Resistance Of ATF Temperature Sensor (GROUP 01, NO. 93-02)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Synthetic Oil For Automatic Transmission Final Drive (GROUP 37, NO. 93-11)
- Automatic Transmission Ag4 - Will Not Move In "D" (GROUP 38, NO. 93-02)
- Auto. Trans. 096 - Shift Point Specifications (GROUP 37, NO. 93-04)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Automatic Transmission 096 - Technical Data (GROUP 37, NO. 92-02)
- Harsh Engagement When Selecting Drive Gear (GROUP 37, NO. 91-04)
- Discontinue Use Of ATF Filter (GROUP 37, NO. 91-03)
- Shift Handle - Installation Procedure (GROUP 37, NO. 91-02)
- Transmission Diagnosis/Measuring Block Values (GROUP D3, NO. 91-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Revised ATF Level Checking Procedure (GROUP 32, NO. 90-01)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
Auxiliary Emission Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- EVAP System Functional Test (TT 20-09-02)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-07)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Volume Air Flow Sensor Position Sensor: New Parts (GROUP 25, NO. 93-03)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- New Control Unit For Cis-E MOTRONIC Systems (GROUP 25, NO. 91-01)
- Repair Group D2 - Cis-E MOTRONIC System (GROUP D2, NO. 90-04)
- Cis-E MOTRONIC - VAG 1551 Fault Discrepancy (GROUP D2, NO. D2-90-T01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Axle Shafts
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Blowers, Superchargers & Turbochargers
- Crankshaft Drive Belt Sprocket Bolt Torque Specs (GROUP 13, NO. 92-03)
- Alternator V-Belt Adjustment (GROUP 13, NO. 92-01)
Body Electrical
- Wiring Harness Repairing (TT 97-01-23)
Body Interior
- Sensor Checking (TT 97-06-64)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Brakes Control Systems
- Sensor Checking (TT 97-06-64)
- Abs/EDL On-Board Diagnostic, DTC Memory Analysis (GROUP 01, NO. 92-01)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Abs Pump Supersession Information (GROUP 45, NO. 91-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Charging Systems
- Wiring Harness Repairing (TT 97-01-23)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Crankshaft Drive Belt Sprocket Bolt Torque Specs (GROUP 13, NO. 92-03)
- Alternator Light On, V Belt Squeals When Wet (GROUP 13, NO. 92-02)
- Alternator V-Belt Adjustment (GROUP 13, NO. 92-01)
- Slot For Woodruff Key Is Missing In Alternator Shaft (GROUP 27, NO. 92-01)
Clutch
- Manual Transmission - Shifting Difficulties (GROUP 30, NO. 93-04)
- Pressure Plate Mounting Bolts Torque Specifications (GROUP 30, NO. 92-02)
- Modified Differential Shaft Roll Pin (GROUP 39, NO. 92-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Communication Devices
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
Cooling System (Mechanical)
- 19-17-01 - Identifying And Mixing VOLKSWAGEN Engine Coolants (U.S. Only) (GROUP 19, NO. 17-01)
- Coolant (Antifreeze), Mixing Precautions (GROUP 19, NO. 02-01)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- Coolant Pump Leakage Troubleshooting (GROUP 19, NO. 93-01)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- 2.0L 16-Valve - Coolant Pump Leaking/DROANING Noise (GROUP 19, NO. 91-01)
Cruise Control Systems
- Cruise Control (A/T) Testing Using Tester VAG 1466 (GROUP 27, NO. 93-06)
- Cruise Control (M/T) Testing Using Tester VAG 1466 (GROUP 27, NO. 93-07)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Speed Sensor Wire G/54 Power Supply To Radio Warning (GROUP 90, NO. 91-01)
- Cruise Contr0L System Checking (Auto & Man Trans) (GROUP 27, NO. 90-02)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
Differentials & Drive Axles
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
Driveshaft & Universal Joints
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Electronic Steering
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Electronic Suspension
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Engine Control Systems
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Silicone Contamination (TT 24-00-35)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-07)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Volume Air Flow Sensor Position Sensor: New Parts (GROUP 25, NO. 93-03)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- New Control Unit For Cis-E MOTRONIC Systems (GROUP 25, NO. 91-01)
- Speed Sensor Wire G/54 Power Supply To Radio Warning (GROUP 90, NO. 91-01)
- Repair Group D2 - Cis-E MOTRONIC System (GROUP D2, NO. 90-04)
- Cis-E MOTRONIC - VAG 1551 Fault Discrepancy (GROUP D2, NO. D2-90-T01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Entertainment Systems
- Radio, Anti-Theft Radio Security Code Retrieval Procedures (GROUP 91, NO. 05-02)
- Radio Diagnosis Instructions (GROUP 91, NO. 94-02)
- Radio Speaker Application (GROUP 91, NO. 91-03)
- Speed Sensor Wire G/54 Power Supply To Radio Warning (GROUP 90, NO. 91-01)
- Radio Cassette HEIDELBERG VI & VII - Shipping (GROUP 91, NO. 91-01)
- HEIDELBERG VI Fixed Coded Radio - Coding (GROUP 91, NO. 89-01)
Exhaust
- Exhaust Restriction Testing Tip (TT 26-09-01)
- Exhaust Heat Shield, Replacement Guidelines (GROUP 26, NO. 08-02)
- Exhaust Rattles On Rear Axle (GROUP 26, NO. 91-02)
Exterior Body Panels
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Incorrect Fuel Level Indication (GROUP 90, NO. 93-01)
Exterior Lights
- Turn Signal / Headlight Dimmer/Flasher Switch INOP (GROUP 94, NO. 93-02)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
Front Suspension
- Front/Rear Tire Cupping/Feather-Edging: Alignment (GROUP 44, NO. 95-01)
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Fuel System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
Fuses & Circuit Breakers
- Wiring Harness Repairing (TT 97-01-23)
- Electrical Wiring Repairs (GROUP 97, NO. 92-01)
Gauges & Instrument Panels
- Speedometer Replacement - Compliance With Regulation (GROUP 90, NO. 97-01)
- Speedometer Replacement - CANADIAN Gov. Regulations (GROUP 90, NO. 96-02)
- Digital Clock Loses Time - Clock Synchronizer Guide (GROUP 90, NO. 93-04)
- Incorrect Fuel Level Indication (GROUP 90, NO. 93-01)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Speedometer Replacing - Disclosure Requirements (GROUP 90, NO. 92-02)
General Servicing
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
Headlights
- Turn Signal / Headlight Dimmer/Flasher Switch INOP (GROUP 94, NO. 93-02)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
HVAC Control Systems
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Air Conditioner Odor (TT 87-97-20)
- A/C System, Retrofitting R12 To R134A (GROUP 87, NO. 95-03)
- Side Windows Fog Up During Heater Operation (GROUP 80, NO. 93-02)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- A/C Compressor Valve Plate, Head & Gasket Replacing (GROUP 87, NO. 91-06)
- A/C Compressor Shaft Seal Replacing (GROUP 87, NO. 91-05)
- A/C Refrigerant System Discharging,Environment Laws (GROUP 87, NO. 91-01)
Identification
- Transmission Code Identification (TT 37-06-12)
Ignition Switch/Steering Lock
- Manual Rotation Of Ignition Switch During Lock Cylinder Or Housing Replacement (TT 28-10-01)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
Ignition System
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- 16V 2L Manual Trans. Throttle Valve Housing Clip (GROUP 24, NO. 92-04)
- Fuel System Management Control Module, Status (GROUP 25, NO. 92-01)
- No Start/Hard Start/Poor Running(DISTRIB Cap Arcing) (GROUP 28, NO. 91-01)
- New Control Unit For Cis-E MOTRONIC Systems (GROUP 25, NO. 91-01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
Interior/Exterior Trim
- Exhaust Heat Shield, Replacement Guidelines (GROUP 26, NO. 08-02)
- Cleaning Non Painted Plastic Exterior Trim Parts (GROUP 66, NO. 91-02)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Ball Latch In Door Handle Discontinued (GROUP 57, NO. 91-02)
- Lock Cylinder Installation - Outer Door Handle (GROUP 57, NO. 90-01)
- Interior Wind Noise Diagnosis & Reduction (GROUP 64, NO. 64-90-T01)
Interior/Illumination Lights
- Turn Signal / Headlight Dimmer/Flasher Switch INOP (GROUP 94, NO. 93-02)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
Locking Hubs
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Lubrication System
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Engine Oil And Oil Additives (GROUP 17, NO. 94-02)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
Manual Steering
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Power Steering Gear Leaks At Low Ambient Temp. (GROUP 48, NO. 93-01)
Manual Trans
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Manual Transmission 02A Changes (GROUP 34, NO. 96-01)
- Manual Transmission 02A Synchronizer Changes (GROUP 35, NO. 96-01)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Universal Transmission Support 3282 (GROUP 00, NO. 93-04)
- Pressure Plate Mounting Bolts Torque Specifications (GROUP 30, NO. 92-02)
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- Installing Shift Lever Rubber Cover (GROUP 34, NO. 92-02)
- Modified Differential Shaft Roll Pin (GROUP 39, NO. 92-01)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- Transmission Jumps Out Of Gear (GROUP 34, NO. 91-01)
- Reverse Gear Binds, Locks Up During Shifting (GROUP 35, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Mechanical
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Dynamic Compression Test Using The Vas 5051B DSO Function (TT 00-07-43)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Engine Replacement - Exchange Alignment Pins (TT 13-07-13)
- All Model Year Engines With Adjustable Cam Timing - Knocking Noise From Chain TENSIONER/Adjuster (TT 15-06-106)
- Oil Consumption, Evaluating (GROUP 17, NO. 05-02)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Alloy Oil Pans, Oil Drain Plug With Sealing Gasket (TT 17-00-08)
- Replacement Engines - Air Pocket In The Oil Lubrication System (TT 17-00-26)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- Drivetrain Vibration/Droning: Replace Engine Mount (GROUP 10, NO. 93-01)
- Flywheel Mounting Bolt - Torque Revision (GROUP 13, NO. 93-03)
- Camshaft Drive Belt TENSIONING - 16 Valve Engine (GROUP 15, NO. 93-02)
- Generator V-Belt Pulley - Removal & Installation (GROUP 27, NO. 93-01)
- Crankshaft Drive Belt Sprocket Bolt Torque Specs (GROUP 13, NO. 92-03)
- Pressure Plate Mounting Bolts Torque Specifications (GROUP 30, NO. 92-02)
- Alternator Light On, V Belt Squeals When Wet (GROUP 13, NO. 92-02)
- 16V 2L Manual Trans. Throttle Valve Housing Clip (GROUP 24, NO. 92-04)
- Fuel System Management Control Module, Status (GROUP 25, NO. 92-01)
- Oil Consumption Definition Volumes (GROUP 17, NO. 92-01)
- Attaching Pressure Plate Or Flywheel To Crankshaft (GROUP 10, NO. 91-01)
- Crankshaft Drive Sprocket Bolt Changed (GROUP 13, NO. 90-01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- V-Belt Squealing - Checking & Adjusting (GROUP 13, NO. 89-02)
Mechanical - Hydraulic
- Portable Gasoline Containers - Filling Information (GROUP 20, NO. 95-01)
- Electrical Contact Enhancer (STABILANT 22A) (GROUP 97, NO. 95-03)
- Adapter VAG 1310/6 For Brake Press. Regulator (GROUP 47, NO. 92-02)
- Brake Fluid Super Dot 4 - Description/Application (GROUP 47, NO. 92-01)
- Improved Fuel Additive ZVW 239 003 (GROUP 20, NO. 20-90-T01)
Mirrors
- Rear Power Window Regulator Rattles/Opens By Itself (GROUP 64, NO. 93-02)
- Central Locking System - Troubleshooting (GROUP 57, NO. 93-01)
- Power Window Troubleshooting (GROUP 64, NO. 91-03)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Central Locking System Discharges Battery (GROUP 57, NO. 91-01)
- Rear Window Regulator Drive Motor Replacement (GROUP 64, NO. 90-03)
Overdrive Unit
- Checking Resistance Of ATF Temperature Sensor (GROUP 01, NO. 93-02)
- Auto. Trans. 096 - Shift Point Specifications (GROUP 37, NO. 93-04)
- Modified Differential Shaft Roll Pin (GROUP 39, NO. 92-01)
- Transmission Diagnosis/Measuring Block Values (GROUP D3, NO. 91-01)
Paint & Coatings
- 00-17-06 - Removing Paint Contaminants From Exterior Paint (GROUP 00, NO. 17-06)
- Technical Bulletin Materials / 3M Distribution Centers (TT 00-09-03)
- Adhesive Material Changed For Flush Bonded Windows (GROUP 64, NO. 95-01)
- Engine Compartment Protection/Acrylic Coating (GROUP 50, NO. 92-02)
- Acid Rain Spots On Paint - Removal Information (GROUP 50, NO. 90-02)
Passive Restraints
- 69-19-01 - Airbag/Pyrotechnic Safety Belt Deployment Inquiries (U.S. Only) (GROUP 69, NO. 97-07)
Rear Suspension
- Front/Rear Tire Cupping/Feather-Edging: Alignment (GROUP 44, NO. 95-01)
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Restraints Control Systems
- Sensor Checking (TT 97-06-64)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Seats
- Installing Child Safety Seat On Front Passenger Seat (GROUP 69, NO. 95-04)
- Rear Child Restraint Anchorages (GROUP 69, NO. 95-05)
- Rear Power Window Regulator Rattles/Opens By Itself (GROUP 64, NO. 93-02)
- Central Locking System - Troubleshooting (GROUP 57, NO. 93-01)
- Front Seat Cover Beading/Piping Visible (GROUP 74, NO. 91-02)
- Power Window Troubleshooting (GROUP 64, NO. 91-03)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Central Locking System Discharges Battery (GROUP 57, NO. 91-01)
- Rear Window Regulator Drive Motor Replacement (GROUP 64, NO. 90-03)
- Automatic Shoulder Belt System Troubleshooting (GROUP 68, NO. 90-02)
Starter
- New Vas 6161 Battery Tester (TT 27-10-02)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- Avoiding Unnecessary Battery Replacement (GROUP 27, NO. 93-10)
- Installation Of Electrical Aftermarket Equipment (GROUP 91, NO. 93-02)
- Fuel System Management Control Module, Status (GROUP 25, NO. 92-01)
- Central Locking System Discharges Battery (GROUP 57, NO. 91-01)
Steering Column
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
Steering Control Systems
- Sensor Checking (TT 97-06-64)
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
Steering Gear
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Power Steering Gear Leaks At Low Ambient Temp. (GROUP 48, NO. 93-01)
Steering Linkage
- Front/Rear Tire Cupping/Feather-Edging: Alignment (GROUP 44, NO. 95-01)
- Power Steering Gear Leaks At Low Ambient Temp. (GROUP 48, NO. 93-01)
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Sun Roof/T-Top/Convertible Top
- Front Power Window Glass Comes Out Of Track (GROUP 64, NO. 91-04)
- Ball Latch In Door Handle Discontinued (GROUP 57, NO. 91-02)
- Lock Cylinder Installation - Outer Door Handle (GROUP 57, NO. 90-01)
Suspension Control Systems
- Sensor Checking (TT 97-06-64)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
System
- Oxygen Sensor Fault Codes (CTT 01-01-01)
- Checking Quality Of Fuel For Gasoline Engines (TT 20-09-01)
- EVAP System Functional Test (TT 20-09-02)
- Engine Replacement, Checking For Debris Lodged In Transferred Assemblies (GROUP 10, NO. 08-01)
- Engine Noise Diagnosis Tips (TT 10-07-71)
- Sensor Checking (TT 97-06-64)
- 02 Sensor DTCS (TT 01-01-17)
- Smoke Checking Intake Manifold Systems (TT 20-01-30)
- Silicone Contamination (TT 24-00-35)
- Intermittent No Start - DTC 00518/00529/00545/00638 (GROUP 01, NO. 97-07)
- Battery Charging Precautions (GROUP 27, NO. 95-01)
- Poor Engine Performance Caused By Bad Fuel (GROUP 20, NO. 94-02)
- Sulfur Odor At Exhaust Pipe (GROUP 26, NO. 94-01)
- Disconnecting Battery Erases OBD Basic Setting (GROUP 27, NO. 94-01)
- Poor DRIVEABILITY: New Oxygen Sensor Wire Harness (GROUP 24, NO. 94-01)
- On Board Diagnostic Troubleshooting Guide Correction (GROUP 01, NO. 93-08)
- Engine Management Harness Connectors: New Terminals (GROUP 97, NO. 93-02)
- Faulty ECT Sensor: Diagnostic Procedure (GROUP 24, NO. 93-04)
- Idle Hunting At Initial Cold Start (GROUP 24, NO. 93-06)
- Volume Air Flow Sensor Position Sensor: New Parts (GROUP 25, NO. 93-03)
- 16V 2L Manual Trans. Throttle Valve Housing Clip (GROUP 24, NO. 92-04)
- Coolant Indicator Led Flashing @ Normal Temperatures (GROUP 90, NO. 92-03)
- Fuel System Management Control Module, Status (GROUP 25, NO. 92-01)
- No Start/Hard Start/Poor Running(DISTRIB Cap Arcing) (GROUP 28, NO. 91-01)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- New Control Unit For Cis-E MOTRONIC Systems (GROUP 25, NO. 91-01)
- Speed Sensor Wire G/54 Power Supply To Radio Warning (GROUP 90, NO. 91-01)
- Repair Group D2 - Cis-E MOTRONIC System (GROUP D2, NO. 90-04)
- Cis-E MOTRONIC - VAG 1551 Fault Discrepancy (GROUP D2, NO. D2-90-T01)
- Gasoline Containing Detergent (GROUP 20, NO. 90-02)
- VAG 1598 Test Box - Description & Connection (GROUP D2, NO. 90-01)
Transfer Case
- Lubricant Capacities/Type Reference Chart (GROUP 00, NO. 90-01)
- CV Joint Diagnosis Inspection Replacement Info (GROUP 40, NO. 90-03)
Transmission Control Systems
- Sensor Checking (TT 97-06-64)
- Shift Lock - Shifting Out Of Park With Dead Battery (TT 37-00-34)
- Ag4 Automatic Transmissions, Fault 00652 Repair (TT 37-98-25)
- Ag4 Automatic Transmission - Fault 00293 (TT 37-97-13)
- Automatic SHIFTLOCK Troubleshooting Tester VAG 1466 (GROUP 37, NO. 93-09)
- Prevention Of Damage To VAG 1551 Diagnostic Tester (GROUP 00, NO. 91-01)
- Cis-E MOTRONIC - VAG 1551 Fault Discrepancy (GROUP D2, NO. D2-90-T01)
Wheel Alignment
- Conversion Chart For Alignment Specifications (GROUP 44, NO. 91-05)
Wheels & Tire System
- DRIVEABILITY Complaints/Noise Concerns (TT 44-06-33)
- Right Rear Tire Blow-Out, Damage Inspection (GROUP 44, NO. 01-03)
- Alloy Wheels Cleaning (GROUP 44, NO. 99-03)
- Rear Tire Wear - Excessive Positive Toe (GROUP 42, NO. 96-01)
- Front/Rear Tire Cupping/Feather-Edging: Alignment (GROUP 44, NO. 95-01)
- Tire Cupping/Feather-Edging (Front/Rear) - Alignment (GROUP 44, NO. 94-02)
- Vehicle Pulls/Drifts To One Side - Rotate Tires (GROUP 44, NO. 94-01)
- Wheels/Tires, Eliminating Vibrations - Information (GROUP 44, NO. 94-03)
- Ice/Snow Driving - Snow Tire/Chain Information (GROUP 44, NO. 93-05)
- Aerosol Tire Inflator/Sealer - Flammability Hazard (GROUP 44, NO. 91-02)
- Eliminating Vibrations - Diagnosis (GROUP 44, NO. 91-01)
- Tire Rotation/Wear Diagnosis/Information (GROUP 44, NO. 90-06)
Window Motors & Regulators
- Rear Power Window Regulator Rattles/Opens By Itself (GROUP 64, NO. 93-02)
- Central Locking System - Troubleshooting (GROUP 57, NO. 93-01)
- Front Power Window Glass Comes Out Of Track (GROUP 64, NO. 91-04)
- Power Window Troubleshooting (GROUP 64, NO. 91-03)
- Illuminated Vanity Mirrors, Replacing Bulbs (GROUP 68, NO. 91-05)
- Ball Latch In Door Handle Discontinued (GROUP 57, NO. 91-02)
- Central Locking System Discharges Battery (GROUP 57, NO. 91-01)
- Rear Window Regulator Drive Motor Replacement (GROUP 64, NO. 90-03)
- Lock Cylinder Installation - Outer Door Handle (GROUP 57, NO. 90-01)
Wiper/Washer Systems
- Fluid Capacity Chart (GROUP 00, NO. 97-08)
- Windshield Wiper Blades Skipping (GROUP 92, NO. 95-02)
- Steering Column Switches, Wire Routing (GROUP 94, NO. 90-01)
- Windshield Wiper Arm Angle Adjust Using Tool Us 9201 (GROUP 92, NO. 90-02)
- Windshield Wiper Blade Smearing (GROUP 92, NO. 90-01)
Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- Wiring Harness Repairing (TT 97-01-23)
- Electrical Wiring Repairs (GROUP 97, NO. 92-01)